Kia Buyers Guide
Click a car name to see the crash test details for that model.
Crash Test Data for 2003 Kia
| Kia Vehicle | Front Star Rating | Side Star Rating | Rollover Resistance Rating | ||
|---|---|---|---|---|---|
| Driver | Passenger | Front Seat | Rear Seat | ||
| 2003 Optima |  | | Not Tested | Not Tested |  |
| 2003 Rio | | | Not Tested | Not Tested | |
| 2003 Rio | | |  | | |
| 2003 Sedona | | | | | |
| 2003 Sorento | | | | |  |
| 2003 Spectra | | | | | |
Service Bulletins for 2003 Kia
| 2003 KIA | |
|---|---|
| Bulletin Number: KT-2008082201 | |
| KIA: ALL MODELS. ARTICLE PROVIDES INFORMATION RELATING TO THE IMPROVED DURABILITY OF BULB LIFE FOR REAR COMBINATION BULB; REAR STOP LAMP/TAIL LAMP BULB UTILIZED ON MULTIPLE KIA MODELS. *PE | |
| 2003 KIA OPTIMA | |
| Bulletin Number: 006 | |
| ENHANCED DIAGNOSIS AND REPAIR FOR P0446/P2422. *TT | |
| Bulletin Number: 01055 | |
| SRS INDICATOR ON WITH DIAGNOSTIC TROUBLE CODE (DTC) 9-3 OR DRIVER'S SEAT BELT BUCKLE REPLACEMENT. *TT | |
| Bulletin Number: 011 | |
| CHARGING SYSTEM CHANGES TO IMPROVE ALTERNATOR OUTPUT IN HIGH AMBIENT TEMPERATURE SEVERE OPERATING CONDITIONS. *TT | |
| Bulletin Number: 012 | |
| OPTIMA CHARGING SYSTEM - V6 ENGINE. *TT | |
| Bulletin Number: 016 | |
| O2 SENSOR ENGINE CONTROL MODULE UPGRADE. *TT | |
| Bulletin Number: 023 | |
| HESITATION FOR A SHORT PERIOD OF TIME AFTER AN INITIAL COLD START. ECM REPROGRAMMING/UPGRADE. *TT | |
| Bulletin Number: 033 | |
| THIS TECHNICAL SERVICE BULLETIN PROVIDES INFORMATION ON A SERVICE CAMPAIGN TO REPLACE THE AIR CONDITIONING SYSTEM RECEIVER-DRIVER ON 2003MY OPTIMA MODELS PRODUCED FROM 11/14/02 THROUGH 4/16/03. *TT | |
| Bulletin Number: 035 | |
| SUPPLEMENT RESTRAINT SYSTEM (SRS) WARNING LAMP ILLUMINATION FOR B1378 AND B1382. *NJ | |
| Bulletin Number: 038 | |
| THIS BULLETIN PROVIDES INFORMATION RELATING TO AN ENGINE HESITATION OR THE ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP (MIL) FOR P0123 (THROTTLE POSITION SENSOR / SWITCH (A) CIRCUIT HIGH INPUT). *NJ | |
| Bulletin Number: 56 | |
| AIR QUALITY SYSTEM. KIA TECH TIMES. *TT | |
| Bulletin Number: 82 | |
| IMPROVED TIMING BELTS FOR THE KIA RIO AND OPTIMA. *TT | |
| Bulletin Number: KT-2008082201 | |
| KIA: ALL MODELS. ARTICLE PROVIDES INFORMATION RELATING TO THE IMPROVED DURABILITY OF BULB LIFE FOR REAR COMBINATION BULB; REAR STOP LAMP/TAIL LAMP BULB UTILIZED ON MULTIPLE KIA MODELS. *PE | |
| Bulletin Number: PS539 | |
| PITSTOP - ENGINE COMPONENT RE-USE GUIDELINES - In general, parts and components removed during engine repairs should be considered serviceable, and should be thoroughly cleaned and transferred to the new engine. | |
| Bulletin Number: SC033 | |
| SERVICE LETTERS TO DEALERS AND OWNERS AND QUESTIONNAIRE REGARDING AIR CONDITIONING RECEIVER-DRIER REPLACEMENT. *TT | |
| Bulletin Number: TSB-026 | |
| KIA: DURING A SERVICE PROCEDURE THAT REQUIRES THE SUBFRAME TO BE REMOVED FROM A 2001-2005 OPTIMA (MS) (V-6 OR I-4), AN IMPROVED SERVICE PROCEDURE HAS BEEN DEVELOPED TO ENHANCE SERVICE EFFICIENCY. *PE | |
| Bulletin Number: TSB-044 | |
| KIA: ECM UPGRADE WITH TP SENSOR REPLACEMENT-MIL ON WITH DTC P2135/P0638. INFORMATION RELATED TO ECM SOFTWARE AND TP SENSOR UPGRADE ON SOME VEHICLES WITH 2.7L ENGINES WHICH MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH | |
| Bulletin Number: TSB-068 | |
| KIA: INTERMITTENT MIL ON WITH NO FAULT CODE STORED; INFORMATION ABOUT DTC P1330. PROVIDES INFORMATION RELATING TO CERTAIN VEHICLES. IN AFFECTED VEHICLES AN INTERMITTENT SHORT TO GROUND IN A CIRCUIT ONLY INTENDED FOR TESTING PURPOSES MAY C | |
| Bulletin Number: TSB-GEN085 | |
| TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with sta | |
| Bulletin Number: TSB-GEN085R1 | |
| TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some example | |
| Bulletin Number: TSBTRA046 | |
| TSB: AUTOMATIC TRANSMISSION FLUID APPLICATION GUIDE - THIS BULLETIN PROVIDES INFORMATION RELATING TO THE CORRECT AUTOMATIC TRANSMISSION FLUIDS THAT ARE REQUIRED FOR EACH KIA MODEL. REFER TO THE SHOP MANUAL ON KGIS FOR THE SPECIFIC KIA MODEL | |
| 2003 KIA RIO | |
| Bulletin Number: 013 | |
| LOW AMBIENT HARD START IN ALL 2003 AND SOME 2004 1.6 DOHC MODELS. REVISED. *TT | |
| Bulletin Number: 034 | |
| THIS BULLETIN PROVIDES INFORMATION ON SERVICE CAMPAIGN TO REPROGRAM THE ENGINE CONTROL MODULE (ECM) ON CERTAIN MODELS PRODUCED FROM 5/4/00 THROUGH 10/31/02. *TT | |
| Bulletin Number: 034 | |
| VOLUNTARY SERVICE CAMPAIGN SC034 TO REPROGRAM THE ENGINE CONTROL MODULE (ECM). VEHICLES EXPERIENCING STALLING DURING IDLING OR AT NEAR STOPPING CONDITIONS. LETTERS TO KIA SERVICE MANAGERS, DEALERS AND QUESTIONS AND ANSWERS SHEET. *TT | |
| Bulletin Number: 034R | |
| THIS REVISED BULLETIN PROVIDES INFORMATION ON SERVICE CAMPAIGN TO REPROGRAM THE ENGINE CONTROL MODULE (ECM) ON CERTAIN MODELS PRODUCED FROM 5/4/00 THROUGH 10/31/02. *TT | |
| Bulletin Number: 04132004 | |
| PENDING RECALL RELATING TO THE FUEL DISTRIBUTOR AND FUEL CONNECTOR ASSEMBLIES. KIA HAS EXPANDED THE RANGE OF AFFECTED VEHICLES. *TT | |
| Bulletin Number: 106 | |
| RIO (BC) ENGINE HARD TO START, RUNS ROUGH AND STALLS -- WHAT TO CHECK -- CRANK POSITION SENSOR (CKP) TONE RING. *NJ | |
| Bulletin Number: 76 | |
| VACUUM LEAK AFTER TSB SC036. KIA TECHNICIAN TIMES. *TT | |
| Bulletin Number: 82 | |
| IMPROVED TIMING BELTS FOR THE KIA RIO AND OPTIMA. *TT | |
| Bulletin Number: 84 | |
| TECHLINE FAQS. KIA TECHNICIAN TIMES. VOLUME 8, ISSUE 4. *TT | |
| Bulletin Number: KT-2008082201 | |
| KIA: ALL MODELS. ARTICLE PROVIDES INFORMATION RELATING TO THE IMPROVED DURABILITY OF BULB LIFE FOR REAR COMBINATION BULB; REAR STOP LAMP/TAIL LAMP BULB UTILIZED ON MULTIPLE KIA MODELS. *PE | |
| Bulletin Number: PS539 | |
| PITSTOP - ENGINE COMPONENT RE-USE GUIDELINES - In general, parts and components removed during engine repairs should be considered serviceable, and should be thoroughly cleaned and transferred to the new engine. | |
| Bulletin Number: TSB-GEN085 | |
| TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with sta | |
| Bulletin Number: TSB-GEN085R1 | |
| TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some example | |
| Bulletin Number: TSBTRA046 | |
| TSB: AUTOMATIC TRANSMISSION FLUID APPLICATION GUIDE - THIS BULLETIN PROVIDES INFORMATION RELATING TO THE CORRECT AUTOMATIC TRANSMISSION FLUIDS THAT ARE REQUIRED FOR EACH KIA MODEL. REFER TO THE SHOP MANUAL ON KGIS FOR THE SPECIFIC KIA MODEL | |
| 2003 KIA RIO CINCO | |
| Bulletin Number: 04132004 | |
| PENDING RECALL RELATING TO THE FUEL DISTRIBUTOR AND FUEL CONNECTOR ASSEMBLIES. KIA HAS EXPANDED THE RANGE OF AFFECTED VEHICLES. *TT | |
| Bulletin Number: KT-2008082201 | |
| KIA: ALL MODELS. ARTICLE PROVIDES INFORMATION RELATING TO THE IMPROVED DURABILITY OF BULB LIFE FOR REAR COMBINATION BULB; REAR STOP LAMP/TAIL LAMP BULB UTILIZED ON MULTIPLE KIA MODELS. *PE | |
| 2003 KIA SEDONA | |
| Bulletin Number: 006 | |
| ENHANCED DIAGNOSIS AND REPAIR FOR P0446/P2422. *TT | |
| Bulletin Number: 008 | |
| AIR CONDITIONING (A/C) DIAGNOSIS AND PERFORMANCE TESTING. *TT | |
| Bulletin Number: 010 | |
| CHARGING SYSTEM CHANGES TO IMPROVE ALTERNATOR OUTPUT DURING HIGH AMBIENT TEMPERATURE SEVERE OPERATING CONDITIONS. *TT | |
| Bulletin Number: 013 | |
| SEDONA (GQ) CORRODED HEATER COOLANT PIPES - ON SOME BUILT FROM MAY 1, 2001, TO AUG. 30, 2005. *NJ UPDATED 6/17/08. *NJ | |
| Bulletin Number: 013 | |
| THROTTLE POSITION SENSOR W/ 3.5L ENGINES. *KB | |
| Bulletin Number: 032 | |
| RECALL CAMPAIGN TO REPROGRAM THE ANTI-LOCK BRAKE SYSTEM (ABS) CONTROL MODULE. *TT | |
| Bulletin Number: 042 | |
| THROTTLE CABLE ASSEMBLY REPLACEMENT RECALL CAMPAIGN. *TT | |
| Bulletin Number: 049 | |
| SAFETY RECALL CAMPAIGN FOR THE REAR WHEEL BEARINGS THAT MAY HAVE WATER INTRUDING INTO THE BEARING AREA THROUGH THE JOINT BETWEEN THE HUBCAP AND HUB AND MAY CONTAMINATE THE GREASE OR DAMAGE THE REAR WHEEL BEARING(S). | |
| Bulletin Number: 81 | |
| REAR WHEEL BEARING TORQUE UPDATE. *TT | |
| Bulletin Number: 82 | |
| IMPROVED CENTER SLIDING DOOR ROLLER ASSEMBLY. *TT | |
| Bulletin Number: KT-2008082201 | |
| KIA: ALL MODELS. ARTICLE PROVIDES INFORMATION RELATING TO THE IMPROVED DURABILITY OF BULB LIFE FOR REAR COMBINATION BULB; REAR STOP LAMP/TAIL LAMP BULB UTILIZED ON MULTIPLE KIA MODELS. *PE | |
| Bulletin Number: PS539 | |
| PITSTOP - ENGINE COMPONENT RE-USE GUIDELINES - In general, parts and components removed during engine repairs should be considered serviceable, and should be thoroughly cleaned and transferred to the new engine. | |
| Bulletin Number: TSB-019 | |
| KIA: INCREASED STEERING EFFORT. IN AREAS WHERE HEAVY ROAD SALT USE OCCURS, INCREASED STEERING EFFORT AND NOISE (FROM STEERING INTERMEDIATE SHAFT) FOR SOME SEDONA. *PE | |
| Bulletin Number: TSB-044 | |
| KIA: ECM UPGRADE WITH TP SENSOR REPLACEMENT-MIL ON WITH DTC P2135/P0638. INFORMATION RELATED TO ECM SOFTWARE AND TP SENSOR UPGRADE ON SOME VEHICLES WITH 2.7L ENGINES WHICH MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH | |
| Bulletin Number: TSB-048 | |
| KIA: POWER SLIDING DOOR REMOE CONTROLLER MOTOR REPLACEMENT. ON SOME VEHICLES, A POWER SLIDING DOOR (PSD) MAY NOT OPEN WHEN USING AN OVERHEAD CONSOLE SWITCH, B PILLAR SWITCH OR REMOTE CONTROL BUTTON. *PE | |
| Bulletin Number: TSB-068 | |
| KIA: INTERMITTENT MIL ON WITH NO FAULT CODE STORED; INFORMATION ABOUT DTC P1330. PROVIDES INFORMATION RELATING TO CERTAIN VEHICLES. IN AFFECTED VEHICLES AN INTERMITTENT SHORT TO GROUND IN A CIRCUIT ONLY INTENDED FOR TESTING PURPOSES MAY C | |
| Bulletin Number: TSB-GEN085 | |
| TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with sta | |
| Bulletin Number: TSB-GEN085R1 | |
| TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some example | |
| Bulletin Number: TSBTRA046 | |
| TSB: AUTOMATIC TRANSMISSION FLUID APPLICATION GUIDE - THIS BULLETIN PROVIDES INFORMATION RELATING TO THE CORRECT AUTOMATIC TRANSMISSION FLUIDS THAT ARE REQUIRED FOR EACH KIA MODEL. REFER TO THE SHOP MANUAL ON KGIS FOR THE SPECIFIC KIA MODEL | |
| 2003 KIA SEDONA EX | |
| Bulletin Number: KT-2008082201 | |
| KIA: ALL MODELS. ARTICLE PROVIDES INFORMATION RELATING TO THE IMPROVED DURABILITY OF BULB LIFE FOR REAR COMBINATION BULB; REAR STOP LAMP/TAIL LAMP BULB UTILIZED ON MULTIPLE KIA MODELS. *PE | |
| 2003 KIA SEPHIA | |
| Bulletin Number: KT-2008082201 | |
| KIA: ALL MODELS. ARTICLE PROVIDES INFORMATION RELATING TO THE IMPROVED DURABILITY OF BULB LIFE FOR REAR COMBINATION BULB; REAR STOP LAMP/TAIL LAMP BULB UTILIZED ON MULTIPLE KIA MODELS. *PE | |
| Bulletin Number: TSB-015 | |
| KIA MOTORS: INSTALLING AN ADDITIONAL GROUND CABLE TO THE BATTERY MAY CAUSE SENSOR PROBLEMS. *RM | |
| 2003 KIA SORENTO | |
| Bulletin Number: 006 | |
| ENHANCED DIAGNOSIS AND REPAIR FOR P0446/P2422. *TT | |
| Bulletin Number: 010 | |
| ELECTRONIC POWER STEERING (EPS) LOGIC CHANGE TO IMPROVE STEERING FEEL. *TT | |
| Bulletin Number: 010103 | |
| SUBJECT REGARDING THE DRIVER SIDE SEAT BELT WIRE HARNESS. *JB | |
| Bulletin Number: 013 | |
| THROTTLE POSITION SENSOR W/ 3.5L ENGINES. *KB | |
| Bulletin Number: 025 | |
| RATTLE NOISE FROM THE JACK COMPARTMENT WHEN DRIVING ON ROUGH ROAD SURFACES. *TT | |
| Bulletin Number: 029 | |
| SERVICE CAMPAIGN TO INSPECT AND REPOSITION THE DRIVER SEAT BELT BUCKLE WIRE HARNESS. *TT | |
| Bulletin Number: 029 | |
| THIS BULLETIN PROVIDES INFORMATION RELATED TO REPLACEMENT OF THE AIR BAG DIAGNOSTIC UNIT (ADU). SOME OWNERS MAY COMPLAIN OF THE SRS WARNING LIGHT ILLUMINATION RESULTING IN ONE OR MORE SEAT TRACK POSITION SENSOR DIAGNOSTIC TROUBLE CODES (DT | |
| Bulletin Number: 031 | |
| HOOD ANTI-CORROSION TREATMENT. *TT | |
| Bulletin Number: 034 | |
| KIA: THERE MAY BE ERRATIC SHIFTING, SHIFT SHOCK, AND A MALFUNCTION LIGHT ON WITH STORED TROUBLE CODES. THIS IS CAUSED BY A PROBLEM WITHIN THE TRANSFER MOTOR. *RM | |
| Bulletin Number: 072 | |
| CRANKSHAFT BOLT REPLACEMENT. *KB | |
| Bulletin Number: 073 | |
| SORENTO ICV REPLACEMENT. *NJ | |
| Bulletin Number: 54 | |
| INFORMATION ON THE NEW 2003 KIA SORENTO. *TT | |
| Bulletin Number: 54 | |
| SUBJECT REGARDING 2003 SORENTO TRAINING. *TT | |
| Bulletin Number: 54 | |
| SUBJECT REGARDING ACCESSORIES FOR THE 2003 SORENTO. *TT | |
| Bulletin Number: 54 | |
| SUBJECT REGARDING SORENTO HIGHLIGHTS. *TT | |
| Bulletin Number: 85 | |
| 2003-2005 CLOCKS NOT HOLDING TIME OR RESETTING - FREQUENTLY ASKED QUESTIONS. *TT | |
| Bulletin Number: 92 | |
| CRANKSHAFT BOLT TORQUE. *TT | |
| Bulletin Number: KT-2008082201 | |
| KIA: ALL MODELS. ARTICLE PROVIDES INFORMATION RELATING TO THE IMPROVED DURABILITY OF BULB LIFE FOR REAR COMBINATION BULB; REAR STOP LAMP/TAIL LAMP BULB UTILIZED ON MULTIPLE KIA MODELS. *PE | |
| Bulletin Number: KT-2008120901 | |
| KIA: HEAD LIGHT BULB LIFE CONCERN. THERE MAY BE CONCERNS OF SHORT HEADLAMP BULB LIFE IN VEHICLES. A NEW RESISTIVE WIRE HARNESS HAS BEEN INTRODUCED TO EXTEND THE LIFE OF THE LOW BEAM BULBS. *PE | |
| Bulletin Number: PS233 | |
| PITSTOP: UNUSUAL FUEL TRIM VALUES AND/OR MISFIRE CODES AFTER INCORRECT ENGINE REPAIR - THIS OUTLINES THE PROCEDURE TO FOLLOW IF AFTER AN ENGINE REPAIR YOU ENCOUNTER A COMPLAINT RELATING TO MIL ON (DTC P)#)X) WITH A MISFIRE DURING ACCELERATI | |
| Bulletin Number: PS233 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: PS539 | |
| PITSTOP - ENGINE COMPONENT RE-USE GUIDELINES - In general, parts and components removed during engine repairs should be considered serviceable, and should be thoroughly cleaned and transferred to the new engine. | |
| Bulletin Number: SC-092 | |
| KIA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. FUEL TANK AIR FILTER REPLACEMENT. *KB | |
| Bulletin Number: TSB-019 | |
| KIA: FUEL TANK AIR FILTER REMINDER. THE AIR FILTER CAN ACCUMULATE DIRT OVER TIME AND NEEDS TO BE MAINTAINED. *RM | |
| Bulletin Number: TSB-044 | |
| KIA: ECM UPGRADE WITH TP SENSOR REPLACEMENT-MIL ON WITH DTC P2135/P0638. INFORMATION RELATED TO ECM SOFTWARE AND TP SENSOR UPGRADE ON SOME VEHICLES WITH 2.7L ENGINES WHICH MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH | |
| Bulletin Number: TSB-068 | |
| KIA: INTERMITTENT MIL ON WITH NO FAULT CODE STORED; INFORMATION ABOUT DTC P1330. PROVIDES INFORMATION RELATING TO CERTAIN VEHICLES. IN AFFECTED VEHICLES AN INTERMITTENT SHORT TO GROUND IN A CIRCUIT ONLY INTENDED FOR TESTING PURPOSES MAY C | |
| Bulletin Number: TSB-GEN085 | |
| TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with sta | |
| Bulletin Number: TSB-GEN085R1 | |
| TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some example | |
| 2003 KIA SPECTRA | |
| Bulletin Number: 009 | |
| COLD ENGINE HARD START. *SCC | |
| Bulletin Number: 017 | |
| CHARGING SYSTEM UPGRADE. *TT | |
| Bulletin Number: 026 | |
| SERVICE CAMPAIGN TO REPLACE ORVR (ON-BOARD REFUELING VAPOR RECOVERY) VALVE. *TT | |
| Bulletin Number: 026 | |
| STEERING WHEEL NOISE. *TT | |
| Bulletin Number: KT-2008082201 | |
| KIA: ALL MODELS. ARTICLE PROVIDES INFORMATION RELATING TO THE IMPROVED DURABILITY OF BULB LIFE FOR REAR COMBINATION BULB; REAR STOP LAMP/TAIL LAMP BULB UTILIZED ON MULTIPLE KIA MODELS. *PE | |
| Bulletin Number: KT-2008110606 | |
| KIA: DOORS LOCKING INTERMITTENTLY WITHOUT DRIVER INPUT FROM THE RKE TRANSMITTER OR KEY SWITCH MAY BE CAUSED BY WEAR ON SWITCH CONTACTS IN DOOR LATCH ASSEMBLY RESULTING IN HIGH RESISTANCE. *PE | |
| Bulletin Number: PS539 | |
| PITSTOP - ENGINE COMPONENT RE-USE GUIDELINES - In general, parts and components removed during engine repairs should be considered serviceable, and should be thoroughly cleaned and transferred to the new engine. | |
| Bulletin Number: TSB-GEN085 | |
| TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with sta | |
| Bulletin Number: TSB-GEN085R1 | |
| TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some example | |
| Bulletin Number: TSBTRA046 | |
| TSB: AUTOMATIC TRANSMISSION FLUID APPLICATION GUIDE - THIS BULLETIN PROVIDES INFORMATION RELATING TO THE CORRECT AUTOMATIC TRANSMISSION FLUIDS THAT ARE REQUIRED FOR EACH KIA MODEL. REFER TO THE SHOP MANUAL ON KGIS FOR THE SPECIFIC KIA MODEL | |
| 2003 KIA SPORTAGE | |
| Bulletin Number: KT-2008082201 | |
| KIA: ALL MODELS. ARTICLE PROVIDES INFORMATION RELATING TO THE IMPROVED DURABILITY OF BULB LIFE FOR REAR COMBINATION BULB; REAR STOP LAMP/TAIL LAMP BULB UTILIZED ON MULTIPLE KIA MODELS. *PE | |
| Bulletin Number: SC104 | |
| SOME KIA SPORTAGE MODELS VEHICLES ARE AFFECTED BY CORROSION WHICH NEEDS ANTI CORROSION PROTECTION. 06/04/14*LJ | |
| Bulletin Number: TSB-GEN085 | |
| TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with sta | |
| Bulletin Number: TSB-GEN085R1 | |
| TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some example | |
Recalls for 2003 Kia
| 2003 KIA OPTIMA | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY |
| Manufacturer: | KIA MOTORS AMERICA, INC. |
| Manufacture Dates: | 10/01/2001 - 11/09/2002 |
| Potential Units Affected: | 25803 |
Defect Description:SOME PASSENGER VEHICLES MAY CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR. Consequence:FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. Action:DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN JUNE 25, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542. | |
| 2003 KIA OPTIMA | |
|---|---|
| NHTSA Campaign ID: | SUSPENSION:FRONT |
| Manufacturer: | KIA MOTORS CORPORATION |
| Manufacture Dates: | 10/06/2000 - 11/19/2003 |
| Potential Units Affected: | 36538 |
Defect Description:KIA MOTORS CORPORATION (KMC) IS RECALLING 36,538 MODEL YEAR 2001-2004 OPTIMA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE STATES DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUBFRAME. OVER TIME, SUCH SUBFRAME CORROSION NEAR THE CONNECTION TO THE LOWER CONTROL ARM CAN LEAD TO WHEEL MISALIGNMENT AND/OR OTHER NOTICEABLE STRESS IN STEERING, OR ACCELERATED ABNORMAL TIRE WEAR. Consequence:CORROSION OF THE FRONT SUBFRAME COULD LEAD TO SEPARATION, POSSIBLY RESULTING IN A VEHICLE CRASH. Action:KMC WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 15, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542. | |
| 2003 KIA RIO | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, GASOLINE:DELIVERY |
| Manufacturer: | KIA MOTORS AMERICA, INC. |
| Manufacture Dates: | 05/04/2000 - 03/31/2004 |
| Potential Units Affected: | 187790 |
Defect Description:ON CERTAIN PASSENGER VEHICLES, THE FUEL INTAKE NIPPLE OF THE FUEL DISTRIBUTOR IS SUBJECT TO FRACTURE OR CRACKING DURING REMOVAL OF THE QUICK CONNECT COUPLING SECURING THE MAIN FUEL TUBE ASSEMBLY TO THE FUEL INTAKE NIPPLE, OR WHEN FORCE IS ACCIDENTALLY APPLIED TO THE INTAKE NIPPLE DURING THE VEHICLE ASSEMBLY PROCESS OR DURING ENGINE COMPARTMENT REPAIRS. Consequence:FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE. Action:DEALERS WILL REPLACE THE FUEL DISTRIBUTOR AND MAIN FUEL TUBE ASSEMBLIES. THE RECALL BEGAN JUNE 18, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542. | |
| 2003 KIA RIO | |
|---|---|
| NHTSA Campaign ID: | CHILD SEAT |
| Manufacturer: | KIA MOTORS AMERICA, INC. |
| Manufacture Dates: | 06/22/2002 - 06/11/2005 |
| Potential Units Affected: | 90865 |
Defect Description:CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' CERTAIN CHILD RESTRAINT ANCHORS WILL NOT FULLY LATCH ONTO THE LOWER LATCH ANCHORS LOCATED BETWEEN THE REAR SEAT BACK AND REAR SEAT CUSHION BECAUSE OF INTERFERENCE BETWEEN THE CHILD SEAT ANCHORS AND A METAL WIRE LOCATED IN THE FRAME OF THE REAR SEAT BACK. UNTIL THE RECALL REPAIR IS COMPLETED, FOLLOW THE INSTRUCTIONS PROVIDED BY YOUR CHILD SEATS MANUFACTURER ON HOW TO PROPERLY INSTALL THE CHILD SEAT WITH YOUR VEHICLE'S REAR SAFETY BELTS RATHER THAN USING THE LATCH SYSTEM. Consequence:IN THE EVENT OF A VEHICLE CRASH, IF THE CHILD SEAT IS NOT PROPERLY INSTALLED, PERSONAL INJURY OR DEATH COULD OCCUR. Action:DEALERS WILL REPLACE THE LOWER ANCHORS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 30, 2006. OWNERS MAY CONTACT KIA AT 1-800-333-4542. | |
| 2003 KIA RIO | |
|---|---|
| NHTSA Campaign ID: | SEAT BELTS:REAR |
| Manufacturer: | KIA MOTORS AMERICA, INC. |
| Manufacture Dates: | 06/22/2002 - 05/24/2003 |
| Potential Units Affected: | 32257 |
Defect Description:CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." WHEN USED WITH CERTAIN CHILD SEATS, THE AUTOMATIC LOCKING RETRACTOR (ALR) FUNCTION IN THE REAR OUTBOARD SEATBELT ASSEMBLIES MAY DISENGAGE. Consequence:IF A CHILD SEAT IS NOT PROPERLY SECURED, THERE IS AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT IN THE EVENT OF A CRASH. Action:DEALERS WILL REPLACE BOTH REAR OUTBOARD SEATBELT ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 15, 2006. OWNERS MAY CONTACT HYUNDAI-KIA AT 1-800-333-4542. | |
| 2003 KIA RIO CINCO | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, GASOLINE:DELIVERY |
| Manufacturer: | KIA MOTORS AMERICA, INC. |
| Manufacture Dates: | 05/04/2000 - 03/31/2004 |
| Potential Units Affected: | 187790 |
Defect Description:ON CERTAIN PASSENGER VEHICLES, THE FUEL INTAKE NIPPLE OF THE FUEL DISTRIBUTOR IS SUBJECT TO FRACTURE OR CRACKING DURING REMOVAL OF THE QUICK CONNECT COUPLING SECURING THE MAIN FUEL TUBE ASSEMBLY TO THE FUEL INTAKE NIPPLE, OR WHEN FORCE IS ACCIDENTALLY APPLIED TO THE INTAKE NIPPLE DURING THE VEHICLE ASSEMBLY PROCESS OR DURING ENGINE COMPARTMENT REPAIRS. Consequence:FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE. Action:DEALERS WILL REPLACE THE FUEL DISTRIBUTOR AND MAIN FUEL TUBE ASSEMBLIES. THE RECALL BEGAN JUNE 18, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542. | |
| 2003 KIA SEDONA | |
|---|---|
| NHTSA Campaign ID: | SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE |
| Manufacturer: | KIA MOTORS AMERICA, INC. |
| Manufacture Dates: | 11/27/2002 - 03/10/2003 |
| Potential Units Affected: | 3375 |
Defect Description:ON CERTAIN PASSENGER VEHICLES, THERE WAS A PROGRAMMING ERROR IN THE ANTI-LOCK BRAKING SYSTEM (ABS) ELECTRONIC CONTROL MODULE LOGIC. THE PROGRAMMING ERROR COULD CAUSE REDUCED BRAKING FORCE AT SPEEDS BELOW 25 MPH, WHICH COULD RESULT IN INCREASED STOPPING DISTANCES. Consequence:SUCH INCREASED STOPPING DISTANCES COULD RESULT IN A CRASH. Action:DEALERS WILL REPROGRAM THE CONTROL MODULE. OWNER NOTIFICATION BEGAN MAY 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542. | |
| 2003 KIA SEDONA | |
|---|---|
| NHTSA Campaign ID: | WHEELS |
| Manufacturer: | KIA MOTORS AMERICA, INC. |
| Manufacture Dates: | 06/24/2003 - 10/29/2004 |
| Potential Units Affected: | 37358 |
Defect Description:ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING. Consequence:WHEEL BEARING FAILURE MAY OCCUR WITHOUT WARNING WHICH COULD RESULT IN A CRASH. Action:DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542. | |
| 2003 KIA SEDONA | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL:CABLES |
| Manufacturer: | KIA MOTORS AMERICA, INC. |
| Manufacture Dates: | - |
| Potential Units Affected: | 118447 |
Defect Description:ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL. Consequence:THIS CAN CAUSE THE CABLE TO STICK, THUS PREVENTING THE ENGINE FROM RETURNING TO IDLE AND CAUSING THE VEHICLE TO MAINTAIN SPEED OR ACCELERATE. SUCH AN EVENT CAN OCCUR WITHOUT WARNING AND COULD CAUSE A CRASH. Action:DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542. | |
| 2003 KIA SEDONA | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL:CABLES |
| Manufacturer: | KIA MOTORS AMERICA, INC. |
| Manufacture Dates: | 03/20/2001 - 04/03/2003 |
| Potential Units Affected: | 89238 |
Defect Description:ON CERTAIN MINI VANS, DURING ASSEMBLY, THE THROTTLE CABLE WOULD TWIST ITSELF OUT OF POSITION. Consequence:THIS CAN PERMIT THE CABLE TO BE HUNG UP, WHICH COULD RESULT IN A CRASH. Action:DEALERS WILL REPLACE THE THROTTLE CABLE FREE OF CHARGE. VEHICLES PRODUCED FROM MARCH 20, 2001 THROUGH NOVEMBER 7, 2001 WILL HAVE A GUIDE CLIP INSTALLED ON THE THROTTLE BODY ASSEMBLY IN ORDER TO ENSURE THAT THE TENSION FORCE CABLE DOES NOT MOVE OUT OF POSITION. VEHICLES MANUFACTURED BEGINNING ON NOVEMBER 8, 2001, ALREADY HAVE THE EXTENDED GUIDE, WHICH ACCOMPLISHES THE SAME OBJECTIVE. THE RECALL BEGAN MARCH 21, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542. | |
| 2003 KIA SEDONA EX | |
|---|---|
| NHTSA Campaign ID: | SEATS |
| Manufacturer: | KIA MOTORS AMERICA, INC. |
| Manufacture Dates: | - 12/01/2003 |
| Potential Units Affected: | 74276 |
Defect Description:ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER SEATS, THE WIRING UNDER THE FRONT SEATS COULD BE MISROUTED, ALLOWING CONTACT WITH METAL SEAT COMPONENTS. Consequence:THIS CONTACT COULD EVENTUALLY RESULT IN A SHORT CIRCUIT CONDITION THAT MAY RESULT IN A FIRE IN THE JUNCTION BOX AREA OF THE VEHICLE. Action:DEALERS WILL INSPECT AND RE-ROUTE THE WIRES UNDER THE POWER SEATS, IF NECESSARY, AS WELL AS INSTALL PROTECTIVE SEAMING WELTS AROUND THOSE WIRES TO BETTER INSULATE THEM. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542. | |
| 2003 KIA SORENTO | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturer: | KIA MOTORS AMERICA, INC. |
| Manufacture Dates: | 06/07/2002 - 08/14/2002 |
| Potential Units Affected: | 2935 |
Defect Description:CERTAIN SPORT UTILITY VEHICLES MAY EXPERIENCE A FUEL LEAK FROM FUEL TUBES NEAR THE FUEL TANK DUE TO AN INTERFERENCE FIT WITH THE VEHICLE FLOOR PANEL. Consequence:FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE. Action:DEALERS WILL REPLACE A SECTION OF THE FUEL LINE. THE RECALL BEGAN ON OCTOBER 10, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542. | |
