Mitsubishi Buyers Guide
Click a car name to see the crash test details for that model.
Crash Test Data for 1997 Mitsubishi
| Mitsubishi Vehicle | Front Star Rating | Side Star Rating | Rollover Resistance Rating | ||
|---|---|---|---|---|---|
| Driver | Passenger | Front Seat | Rear Seat | ||
| 1997 Eclipse |  | | Not Tested | Not Tested | Not Tested |
| 1997 Galant | | |  |  | Not Tested |
| 1997 Montero | | | Not Tested | Not Tested | Not Tested |
Service Bulletins for 1997 Mitsubishi
| 1997 MITSUBISHI 3000GT | |
|---|---|
| Bulletin Number: 0013005 | |
| THIS BULLETIN CONTAINS OBD-II DRIVE CYCLE PROCEDURES AND WARRANTY CLAIM INFORMATION FOR OBD-II DRIVE CYCLE ON AFFECTED VEHICLES. *TT | |
| Bulletin Number: 0213020 | |
| NEW AND REVISED INFORMATION RELATING TO READINESS TEST STATUS DESCRIPTIONS AND PROCEDURES. *TT | |
| Bulletin Number: 0313005 | |
| OBD-II DRIVE CYCLE. *TT | |
| Bulletin Number: 94 | |
| 5-SPEED TRANSFER CASE ASSEMBLY IDENTIFICATION. *TT | |
| Bulletin Number: 97040100003 | |
| DESCRIBING HOW TO REPROGRAM THE HOMELINK TRANSMITTER. *YC | |
| Bulletin Number: 97090152B003 | |
| SERVICE MANUAL REVISION ON SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CAUTIONS AND WARNINGS. *YC | |
| Bulletin Number: 97090154008 | |
| INFORMATION CONTAINING NEW AND REVISED PROCEDURES FOR ADJUSTING HEADLIGHT AIM ON AFFECTED VEHICLES. *YC | |
| Bulletin Number: 97110154013 | |
| INFORMATION CONTAINING ADDITIONAL GLASS ANTENNA CAUTIONS AND INSPECTION PROCEDURES. *YC | |
| Bulletin Number: 9816002 | |
| THE CORRECTIONS TO STARTER RELAY TROUBLESHOOTING INSTRUCTIONS SERVICE MANUAL. YD | |
| Bulletin Number: 9922003 | |
| THIS BULLETIN CONTAINS RECOMMENDED MANUAL TRANSMISSION / TRANSAXLE MAINTENANCE INFORMATION. *TT | |
| Bulletin Number: 9923010 | |
| THIS BULLETIN CONTAINS RECOMMENDED AUTOMATIC TRANSMISSION / TRANSAXLE MAINTENANCE INFORMATION. *TT | |
| Bulletin Number: TSB-19-00-008 | |
| This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label. | |
| Bulletin Number: TSB9622005 | |
| ADDITIONAL MANUAL TRANSAXLE SHIFT LEVER OPERATIONAL INSPECTION - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9631003R | |
| 1997 TIRE CHAIN USAGE. *TW | |
| Bulletin Number: TSB9700001 | |
| ADDITIONAL SCHEDULED MAINTENANCE (DISTRIBUTOR CAP AND ROTOR)- SERVICE MANUAL REVISION. *JD | |
| Bulletin Number: TSB9700005 | |
| MUT-II SCAN TOOL WARRANTY. *TW | |
| Bulletin Number: TSB9711002 | |
| NEW VALVE LASH ADJUSTER NOISE CHECKING AND TROUBLESHOOTING PROCEDURES. *JD | |
| Bulletin Number: TSB9711010 | |
| CYLINDER HEAD BOLT INSTALLATION - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9711015 | |
| THROTTLE BODY PROCEDURES (ECLIPSE/ECLIPSE SPYDER, MIRAGE, 3000GT) - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9713009 | |
| EGR AND PURGE SOLENOID LOCATIONS - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9716006 | |
| GENERATOR STATOR REMOVAL (3000GT AND 1997 MIRAGE) - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9723015 | |
| INFORMATION ABOUT IMPROVED AUTOMATIC TRANSAXLE END CLUTCH. *TT | |
| Bulletin Number: TSB9737A003 | |
| NEW POWER STEERING HOSE - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9752B002 | |
| ADDITIONAL SRS AIR BAG TROUBLESHOOTING PROCEDURES- SERVICE MANUAL REVISION. *JD | |
| Bulletin Number: TSB9754015 | |
| REPAIR PROCEDURES FOR AUDIO FAILURE ON VARIOUS MODEL YEARS. *YC | |
| Bulletin Number: TSB9813005 | |
| VEHICLES MAY EXPERIENCE LONG COLD START TIMES, SAG DURING WARM-UP, AND STALLING. *TT | |
| Bulletin Number: TSB985001 | |
| SERVICE MANUAL REVISION ON A/C CLUTCH AIR GAP. *YC | |
| Bulletin Number: TT237 | |
| This is a service newsletter (Tech Talk) that was sent out to dealers. | |
| 1997 MITSUBISHI DIAMANTE | |
| Bulletin Number: 0013005 | |
| THIS BULLETIN CONTAINS OBD-II DRIVE CYCLE PROCEDURES AND WARRANTY CLAIM INFORMATION FOR OBD-II DRIVE CYCLE ON AFFECTED VEHICLES. *TT | |
| Bulletin Number: 0313005 | |
| OBD-II DRIVE CYCLE. *TT | |
| Bulletin Number: 0313007 | |
| THE LOW FUEL WARNING LIGHT MAY NOT ILLUMINATE UNTIL AFTER THE FUEL GAUGE REACHES E. *TT | |
| Bulletin Number: 0317006 | |
| TEST SPECIFICATIONS FOR THE CRUISE CONTROL VACUUM PUMP ARE INCORRECTLY PRINTED IN THE AFFECTED SERVICE MANUALS. *PH | |
| Bulletin Number: 0323006 | |
| TORQUE CONVERTER SHUDDER, SURGE, AND/OR VIBRATION (POSSIBLY INTERMITTENT) WHEN DRIVING 35-50 MPH AT STEADY THROTTLE. *TT | |
| Bulletin Number: 0336001 | |
| REVISED PARKING BRAKE ADJUSTMENT SPECIFICATIONS - SERVICE MANUAL REVISION. *TT | |
| Bulletin Number: 0352A001 | |
| CENTER CONSOLE LID LATCH REPLACEMENT. *TT | |
| Bulletin Number: 0627001 | |
| REAR AXLE KNUCKLE ASSEMBLY BUSHING REPLACEMENT - SERVICE MANUAL REVISION. *TT | |
| Bulletin Number: 09012002 | |
| POWER SEAT MEMORY FUNCTION. *EH | |
| Bulletin Number: 121201 | |
| SUBJECT REGARDING HEATER CORE LEAKAGE.*JB | |
| Bulletin Number: 78 | |
| SUBJECT REGARDING HEATER CORE GASKET FOR HEATER CORE LEAKAGE. *TT | |
| Bulletin Number: 93 | |
| VIBRATION INCREASING WITH SPEED. *TT | |
| Bulletin Number: 93 | |
| VIBRATION INCREASING WITH SPEED. *TT | |
| Bulletin Number: 97040100003 | |
| DESCRIBING HOW TO REPROGRAM THE HOMELINK TRANSMITTER. *YC | |
| Bulletin Number: 97110123014 | |
| SOME CUSTOMERS MAY REPORT HARSH SHIFTING DURING 2-3 UPSHIFT. *YC | |
| Bulletin Number: 97110135006 | |
| SERVICE MANUAL REVISION ON BRAKE BOOSTER PUSH ROD ADJUSTMENT. *YC | |
| Bulletin Number: 97110154014 | |
| INFORMATION CONTAINING CORRECTIONS TO WIRING DIAGRAMS FOR THE RADIO, TAPE PLAYER, CD PLAYER, SPEAKER, AND ANTENNA. *YC | |
| Bulletin Number: 9742A002 | |
| REMINDER TO DEALERS - ENSURE THAT THE RAP-FILM IS REMOVED FROM AROUND THE WASHER NOZZELS DURING PDI (PRE DELIVERY INSPECTION). *TW | |
| Bulletin Number: 98070120031 | |
| CONCERNS REGARDING A/C IDLER PULLEY NOISE. *YC | |
| Bulletin Number: 9837A004 | |
| REVISED POWER STEERING RACK OVERHAUL PROCEDURES SERVICE MANUAL REVISION. YD | |
| Bulletin Number: 9923010 | |
| THIS BULLETIN CONTAINS RECOMMENDED AUTOMATIC TRANSMISSION / TRANSAXLE MAINTENANCE INFORMATION. *TT | |
| Bulletin Number: TSB0011003 | |
| THIS BULLETIN CONTAINS REVISED PROCEDURES FOR ADJUSTING THE TIMING BELT AUTO TENSIONER. *TT | |
| Bulletin Number: TSB0011004 | |
| INFORMATION CONCERNING THE DELETION OF THE AIR CONDITIONING COMPRESSOR / GENERATOR BELT IDLER PULLEY. *TT | |
| Bulletin Number: TSB0013003 | |
| INFORMATION CONTAINING RECOMMENDED FUELS FOR CERTAIN VEHICLES. *TT | |
| Bulletin Number: TSB0017001 | |
| THIS BULLETIN CONTAINS CORRECTED VOLTAGE CHECK SPECIFICATIONS FOR THE CRUISE CONTROL SWITCH. *TT | |
| Bulletin Number: TSB0100007 | |
| SOME CUSTOMER SMAY NOT UNDERSTAND HOW TO OPEN THE TRUNK LID USING THE REMOTE KEYLESS (RKE) TRANSMITTER, OR HOW TO DEFROST THE WINDSHIELD. *TT | |
| Bulletin Number: TSB0123010 | |
| SOME CUSTOMERS MAY COMPLAIN OF SHUDDER, SURGE, AND / OR VIBRATION WHEN DRIVING 35 - 50 MPH AT STEADY THROTTLE. THIS CONDITION MAY BE DUE TO THE BREAKDOWN OF THE SPII A/T FLUID, CREATING A TORQUE CONVERTER DAMPER CLUTCH SHUDDER. | |
| Bulletin Number: TSB0142A001 | |
| INFORMATION ON TRUNK LID RELEASE KITS FOR CONFINEMENT WITHIN TRUNK. *JB | |
| Bulletin Number: TSB0242A001 | |
| SUBJECT REGARDING DOOR GLASS ADJUSTMENT - SERVICE MANUAL REVISION. *TT | |
| Bulletin Number: TSB-19-00-008 | |
| This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label. | |
| Bulletin Number: TSB9631003R | |
| 1997 TIRE CHAIN USAGE. *TW | |
| Bulletin Number: TSB9700005 | |
| MUT-II SCAN TOOL WARRANTY. *TW | |
| Bulletin Number: TSB9736001 | |
| PARKING BRAKE SQUEAL. *TW | |
| Bulletin Number: TSB9752A003 | |
| DIAMANTE ES MODELS - COIN BOX COVER WILL NOT LOCK. *TW | |
| Bulletin Number: TSB9754005 | |
| VOLUME 2 SERVICE MANUAL CORRECTIONS - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9811003 | |
| SERVICE MANUAL REVISION ON CONNECTING ROD/CRANKSHAFT BEARING SELECTION. *YC | |
| Bulletin Number: TSB9813006 | |
| SERVICE BULLETIN ON REVISED AIR FLOW SENSOR SPECIFICATIONS & ECM CONNECTOR. *YC | |
| Bulletin Number: TSB9837A003 | |
| REPAIR PROCEDURES FOR CORRECTING A STEERING WHEEL SHUDDER OR VIBRATION. *YC | |
| Bulletin Number: TSB9852A002 | |
| VIBRATION NOTICED IN THE REAR VIEW MIRROR WITH THE ENGINE RUNNING. *YC | |
| Bulletin Number: TSB9852B002 | |
| SERVICE MANUAL REVISION ON SRS AIR BAG CAUTION AND WARNING LABEL REVISIONS. *YC | |
| Bulletin Number: TSB9854005 | |
| SERVICE MANUAL REVISION ON CORRECTED INSTRUMENT PANEL HARNESS CONNECTOR NUMBERS. *YC | |
| Bulletin Number: TSB9854006 | |
| INFORMATION ON THE REAR COMBINATION LIGHT CONNECTOR LOCATIONS ON THE TAILLIGHT, SIDE MARKER LIGHT AND LICENSE PLATE LIGHT CIRCUIT DIAGRAM. *YC | |
| Bulletin Number: TSB9855003 | |
| SUBJECT ON CORRECTED A/C INSPECTION CONNECTOR TERMINAL NUMBERS AND SENSOR LOCATIONS. *YC | |
| Bulletin Number: TT237 | |
| This is a service newsletter (Tech Talk) that was sent out to dealers. | |
| 1997 MITSUBISHI ECLIPSE | |
| Bulletin Number: 0013005 | |
| THIS BULLETIN CONTAINS OBD-II DRIVE CYCLE PROCEDURES AND WARRANTY CLAIM INFORMATION FOR OBD-II DRIVE CYCLE ON AFFECTED VEHICLES. *TT | |
| Bulletin Number: 01 | |
| SUBJECT REGARDING DIAGNOSTIC TROUBLE CODE P1390 PCM RELEARN. *TT | |
| Bulletin Number: 0255002 | |
| SUBJECT REGARDING CORRECTED AIR CONDITIONER MAGNETIC CLUTCH SERVICE PROCEDURES. *JG | |
| Bulletin Number: 0313005 | |
| OBD-II DRIVE CYCLE. *TT | |
| Bulletin Number: 48 | |
| INFORMATION REGARDING INTERMITTENT LOSS OF CRUISE CONTROL. *TT | |
| Bulletin Number: 48 | |
| SUBJECT REGARDING CHRYSLER REPROGRAMMING CATRIDGE ROUND-UP. *TT | |
| Bulletin Number: 67 | |
| SUBJECT REGARDING POWER STEERING PUMP REPLACEMENT. *JB | |
| Bulletin Number: 80 | |
| SUBJECT REGARDING REPLACEMENT CRANK ANGLE SENSOR WIRE COLORS. *TT | |
| Bulletin Number: 83 | |
| VEHICLE TECHNICAL INFORMATION REGARDING MANUAL TRANSMISSION FLUID. *TT | |
| Bulletin Number: 84 | |
| SUBJECT REGARDING MANUAL TRANSMISSION FLUID. *TT | |
| Bulletin Number: 89 | |
| NO START. 1995-99 420A WITH MANUAL TRANSMISSION. *TT | |
| Bulletin Number: 97040100003 | |
| DESCRIBING HOW TO REPROGRAM THE HOMELINK TRANSMITTER. *YC | |
| Bulletin Number: 97040117001 | |
| CONTAINING THE CORRECT VACUUM HOSE ROUTING ILLUSTRATIONS FOR AFFECTED VEHICLES. *YC | |
| Bulletin Number: 97090152B003 | |
| SERVICE MANUAL REVISION ON SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CAUTIONS AND WARNINGS. *YC | |
| Bulletin Number: 97090154006 | |
| REVISED HEADLIGHT AIMING ADJUSTMENT PROCEDURES. *YC | |
| Bulletin Number: 97090199017 | |
| SUBJECT ON CYLINDER HEAD DISTORTION INSPECTION. *YC | |
| Bulletin Number: 97110123013 | |
| ACCELERATING PRIOR TO A COMPLETE STOP, THE AUTOMATIC TRANSMISSION MAY SHIFT FROM THIRD GEAR TO SECOND GEAR WITH SOME HARSHNESS. *YC | |
| Bulletin Number: 97110154013 | |
| INFORMATION CONTAINING ADDITIONAL GLASS ANTENNA CAUTIONS AND INSPECTION PROCEDURES. *YC | |
| Bulletin Number: 98070120004 | |
| CONDITION WITH ENGINE OVERHEATING. *YC | |
| Bulletin Number: 98070120023 | |
| INFORMATION ON CONVERTIBLE TOP SIDE RAIL FOAM SEAL INSTALLATION. *YC | |
| Bulletin Number: 98070120024 | |
| VEHICLE EXPERIENCING DOOR POPPING / KNOCKING NOISE. *YC | |
| Bulletin Number: 98070120025 | |
| EXPERIENCING LEAKAGE FROM WINDSHIELD WASHER NOZZLE. *YC | |
| Bulletin Number: 98070120028 | |
| BRIEF INFORMATION ON ADHESION PROMOTERS. *YC | |
| Bulletin Number: 9922003 | |
| THIS BULLETIN CONTAINS RECOMMENDED MANUAL TRANSMISSION / TRANSAXLE MAINTENANCE INFORMATION. *TT | |
| Bulletin Number: 9923010 | |
| THIS BULLETIN CONTAINS RECOMMENDED AUTOMATIC TRANSMISSION / TRANSAXLE MAINTENANCE INFORMATION. *TT | |
| Bulletin Number: TSB0011001 | |
| INFORMATION AND RELATED INSTALLATION PROCEDURES ABOUT A NEW, IMPROVED HEAD GASKET FOR VEHILCES EQUIPPED WITH THE 2.0L, NON-TURBO, 420A ENGINE. *TT | |
| Bulletin Number: TSB0052A010 | |
| THIS BULLETIN DESCRIBES HOW TO INSTALL THE NEW POWER SEAT SLIDE MOTOR. *TT | |
| Bulletin Number: TSB0123004 | |
| THIS BULLETIN CONTAINS CORRECTED DIAGNOSTIC TROUBLE CODE 41 (SOLENOID CIRCUIT ERROR - LR) DIAGNOSIS CHARTS FOR REVISED SERVICE MANUAL PAGES. *JB | |
| Bulletin Number: TSB0155003 | |
| SERVICE MANUAL REVISION ON REVOLUTION PICK-UP SENSOR RESISTANCE. *JB | |
| Bulletin Number: TSB-19-00-008 | |
| This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label. | |
| Bulletin Number: TSB9622005 | |
| ADDITIONAL MANUAL TRANSAXLE SHIFT LEVER OPERATIONAL INSPECTION - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9631003R | |
| 1997 TIRE CHAIN USAGE. *TW | |
| Bulletin Number: TSB9654012 | |
| ANTENNA TIGHTENING TORQUE. *TW | |
| Bulletin Number: TSB9700005 | |
| MUT-II SCAN TOOL WARRANTY. *TW | |
| Bulletin Number: TSB9711001 | |
| REVISED VALVE AND VALVE GUIDE SPECIFICATIONS (420A ENGINE)- SERVICE MANUAL REVISION. *JD | |
| Bulletin Number: TSB9711002 | |
| NEW VALVE LASH ADJUSTER NOISE CHECKING AND TROUBLESHOOTING PROCEDURES. *JD | |
| Bulletin Number: TSB9711004 | |
| CRANKSHAFT BEARING SELECTION PROCEDURE - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9711012 | |
| CHANGED CAMSHAFT POSITION SENSING CYLINDER REMOVAL SEQUENCE - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9711014 | |
| VALVE GUIDE REPLACEMENT PROCEDURES (ECLIPSE/ECLIPSE SPYDER) - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9711015 | |
| THROTTLE BODY PROCEDURES (ECLIPSE/ECLIPSE SPYDER, MIRAGE, 3000GT) - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9715001 | |
| HESITATION AND/OR SURGE AT HIGHER SPEEDS (4G64 2.4L SOHC ENGINE). *JD | |
| Bulletin Number: TSB9716002 | |
| DTC 58 - INTAKE AIR TEMPERATURE SENSOR HARNESS. *TW | |
| Bulletin Number: TSB9716004 | |
| GENERATOR STATOR REMOVAL - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9723002 | |
| 2/4 CLUTCH PISTON RETAINER PARTS IDENTIFICATION (F4AC1 TRANSAXLE). *JD | |
| Bulletin Number: TSB9723015 | |
| INFORMATION ABOUT IMPROVED AUTOMATIC TRANSAXLE END CLUTCH. *TT | |
| Bulletin Number: TSB9726002 | |
| DRIVESHAFT (FRONT AXLE) REMOVAL PROCEDURES - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9737A001 | |
| POWER STEERING BELT ALIGNMENT AND TROUBLESHOOTING PROCEDURES. *JD | |
| Bulletin Number: TSB9737A003 | |
| NEW POWER STEERING HOSE - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9742A004 | |
| WINDSHIELD WIND NOISE. *JD | |
| Bulletin Number: TSB9742A008 | |
| REAR WHEEL HOUSING WATER LEAK. *TW | |
| Bulletin Number: TSB9752A001 | |
| DOOR TRIM DEFROSTER GARNISH. *JD | |
| Bulletin Number: TSB9752B002 | |
| ADDITIONAL SRS AIR BAG TROUBLESHOOTING PROCEDURES- SERVICE MANUAL REVISION. *JD | |
| Bulletin Number: TSB9754001 | |
| COOLING AND A/C SYSTEM CIRCUIT DIAGRAM CORRECTIONS (DELETED FAN MOTOR RELAY [HI])- SERVICE MANUAL REVISION. *JD | |
| Bulletin Number: TSB9754015 | |
| REPAIR PROCEDURES FOR AUDIO FAILURE ON VARIOUS MODEL YEARS. *YC | |
| Bulletin Number: TSB9813005 | |
| VEHICLES MAY EXPERIENCE LONG COLD START TIMES, SAG DURING WARM-UP, AND STALLING. *TT | |
| Bulletin Number: TSB9813012 | |
| THIS BULLETIN DESCRIBES THE OPERATION OF THE EVAPORATIVE EMISSION CONTROL LEAK DETECTION SYSTEM AND HOW TO DIANOSE DIAGNOSTIC TROUBLE CODES RELEVANT TO THIS SYSTEM. *YC | |
| Bulletin Number: TSB9823003 | |
| EXPERIENCING POOR A/T SHIFT QUALITY. *YC | |
| Bulletin Number: TSB9823006 | |
| CORRECTED INFORMATION CONCERNING THE UNDERDRIVE ACCUMULATOR SPRING. *YC | |
| Bulletin Number: TSB9823015 | |
| CONCERNS WITH DELAYED TRANSAXLE ENGAGEMENT. *YC | |
| Bulletin Number: TSB9834001 | |
| PROCEDURES FOR REPAIRING ABNORMAL NOISES FROM THE REAR SUSPENSION. *YC | |
| Bulletin Number: TSB9835004 | |
| SERVICE MANUAL REVISION ON ABS DATA LIST REFERENCE AND ACTUATOR TEST REFERENCE TABLES. *YC | |
| Bulletin Number: TSB9837A005 | |
| SUBJECT REGARDING POWER STEERING BELT ALIGNEMENT AND TROUBLESHOOTING PROCEDURES. *YC | |
| Bulletin Number: TSB985001 | |
| SERVICE MANUAL REVISION ON A/C CLUTCH AIR GAP. *YC | |
| Bulletin Number: TSB9851004 | |
| SOME VEHICLES MAY EXPERIENCE FRONT WINDSHIELD WASHER NOZZLE LEAKAGE. *YC | |
| Bulletin Number: TSB9911007 | |
| INFORMATION REGARDING CYLINDER HEAD GASKETS FOR REMANUFACTURED SHORT BLOCKS. *TT | |
| Bulletin Number: TSB9913001 | |
| PCM REPROGRAMMING & REPLACEMENT SUMMARY (420A ENGINE). *TT | |
| Bulletin Number: TSB9934001 | |
| CUSTOMERS MAY COMPLAIN OF A SQUEAKING, A HARD RUBBING NOISE, AND / OR A LIGHT TAPPING OR KNOCKING SOUND FROM THE REAR SUSPENSION WHEN DRIVING OVER BUMPS. *TT | |
| Bulletin Number: TSB9942A004 | |
| VEHICLES EXHIBITING POPPING AND/OR CREAKING NOISE IN DOOR WINDOW GLASS. *TT | |
| Bulletin Number: TT237 | |
| This is a service newsletter (Tech Talk) that was sent out to dealers. | |
| 1997 MITSUBISHI ECLIPSE SPYDER | |
| Bulletin Number: 0255002 | |
| SUBJECT REGARDING CORRECTED AIR CONDITIONER MAGNETIC CLUTCH SERVICE PROCEDURES. *JG | |
| Bulletin Number: 48 | |
| EXHIBITING ROUGH IDLE AFTER WARM-UP. *TT | |
| Bulletin Number: 67 | |
| SUBJECT REGARDING POWER STEERING PUMP REPLACEMENT. *JB | |
| Bulletin Number: 9922003 | |
| THIS BULLETIN CONTAINS RECOMMENDED MANUAL TRANSMISSION / TRANSAXLE MAINTENANCE INFORMATION. *TT | |
| Bulletin Number: 9923010 | |
| THIS BULLETIN CONTAINS RECOMMENDED AUTOMATIC TRANSMISSION / TRANSAXLE MAINTENANCE INFORMATION. *TT | |
| Bulletin Number: TSB0052A010 | |
| THIS BULLETIN DESCRIBES HOW TO INSTALL THE NEW POWER SEAT SLIDE MOTOR. *TT | |
| Bulletin Number: TSB0155003 | |
| SERVICE MANUAL REVISION ON REVOLUTION PICK-UP SENSOR RESISTANCE. *JB | |
| Bulletin Number: TSB-19-00-008 | |
| This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label. | |
| Bulletin Number: TSB9813005 | |
| VEHICLES MAY EXPERIENCE LONG COLD START TIMES, SAG DURING WARM-UP, AND STALLING. *TT | |
| Bulletin Number: TSB9823014 | |
| EXPERIENCING A/T HARSH 3-2 DOWNSHIFTS. *TT | |
| Bulletin Number: TSB9834001 | |
| PROCEDURES FOR REPAIRING ABNORMAL NOISES FROM THE REAR SUSPENSION. *YC | |
| Bulletin Number: TSB9842A003 | |
| SERVICE MANUAL REVISION ON ELECTRIC CONVERTIBLE TOP SUPPLEMENT. *YC | |
| Bulletin Number: TSB9842A009 | |
| SOME VEHICLES MAY EXHIBIT A SQUEAK AND / OR RATTLE AT THE WINDSHIELD HEADER. *YC | |
| Bulletin Number: TSB985001 | |
| SERVICE MANUAL REVISION ON A/C CLUTCH AIR GAP. *YC | |
| Bulletin Number: TSB9851004 | |
| SOME VEHICLES MAY EXPERIENCE FRONT WINDSHIELD WASHER NOZZLE LEAKAGE. *YC | |
| Bulletin Number: TSB9934001 | |
| CUSTOMERS MAY COMPLAIN OF A SQUEAKING, A HARD RUBBING NOISE, AND / OR A LIGHT TAPPING OR KNOCKING SOUND FROM THE REAR SUSPENSION WHEN DRIVING OVER BUMPS. *TT | |
| Bulletin Number: TSB9942A004 | |
| VEHICLES EXHIBITING POPPING AND/OR CREAKING NOISE IN DOOR WINDOW GLASS. *TT | |
| Bulletin Number: TSB9942A005 | |
| SOME CUSTOMERS MAY COMPLAIN OF EXCESSIVE WATER ENTERING THE VEHICLE AROUND THE TOPSTACK ASSEMBLY. *TT | |
| Bulletin Number: TSB9942A007 | |
| THIS BULLETIN CONTAINS PROCEDURES FOR PREVENTING AND REPAIRING BENT TOP STACK CONTROL LINKS. *TT | |
| Bulletin Number: TT237 | |
| This is a service newsletter (Tech Talk) that was sent out to dealers. | |
| 1997 MITSUBISHI EXPO | |
| Bulletin Number: 0013005 | |
| THIS BULLETIN CONTAINS OBD-II DRIVE CYCLE PROCEDURES AND WARRANTY CLAIM INFORMATION FOR OBD-II DRIVE CYCLE ON AFFECTED VEHICLES. *TT | |
| Bulletin Number: 0313005 | |
| OBD-II DRIVE CYCLE. *TT | |
| Bulletin Number: TSB-19-00-008 | |
| This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label. | |
| Bulletin Number: TT237 | |
| This is a service newsletter (Tech Talk) that was sent out to dealers. | |
| 1997 MITSUBISHI EXPO LRV | |
| Bulletin Number: 0013005 | |
| THIS BULLETIN CONTAINS OBD-II DRIVE CYCLE PROCEDURES AND WARRANTY CLAIM INFORMATION FOR OBD-II DRIVE CYCLE ON AFFECTED VEHICLES. *TT | |
| Bulletin Number: 0313005 | |
| OBD-II DRIVE CYCLE. *TT | |
| Bulletin Number: TSB-19-00-008 | |
| This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label. | |
| Bulletin Number: TT237 | |
| This is a service newsletter (Tech Talk) that was sent out to dealers. | |
| 1997 MITSUBISHI FB | |
| Bulletin Number: TSB-19-00-008 | |
| This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label. | |
| Bulletin Number: TT237 | |
| This is a service newsletter (Tech Talk) that was sent out to dealers. | |
| 1997 MITSUBISHI GALANT | |
| Bulletin Number: 0013005 | |
| THIS BULLETIN CONTAINS OBD-II DRIVE CYCLE PROCEDURES AND WARRANTY CLAIM INFORMATION FOR OBD-II DRIVE CYCLE ON AFFECTED VEHICLES. *TT | |
| Bulletin Number: 0255002 | |
| SUBJECT REGARDING CORRECTED AIR CONDITIONER MAGNETIC CLUTCH SERVICE PROCEDURES. *JG | |
| Bulletin Number: 0313005 | |
| OBD-II DRIVE CYCLE. *TT | |
| Bulletin Number: 48 | |
| EXHIBITING ROUGH IDLE AFTER WARM-UP. *TT | |
| Bulletin Number: 67 | |
| SUBJECT REGARDING POWER STEERING PUMP REPLACEMENT. *JB | |
| Bulletin Number: 97040100003 | |
| DESCRIBING HOW TO REPROGRAM THE HOMELINK TRANSMITTER. *YC | |
| Bulletin Number: 97090152B003 | |
| SERVICE MANUAL REVISION ON SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CAUTIONS AND WARNINGS. *YC | |
| Bulletin Number: 97090154006 | |
| REVISED HEADLIGHT AIMING ADJUSTMENT PROCEDURES. *YC | |
| Bulletin Number: 97090154011 | |
| MULTI-PURPOSE FUSE CAPACITY IS INCORRECTLY SPECIFIED IN THE AFFECTED SERVICE MANUAL PAGES. *YC | |
| Bulletin Number: 97110142A013 | |
| VEHICLES MAY EXHIBIT A CONDITION WHERE THE DRIVER'S SIDE SUNROOF SIDE DECORATION COVER COMES LOOSE. *YC | |
| Bulletin Number: 97110154013 | |
| INFORMATION CONTAINING ADDITIONAL GLASS ANTENNA CAUTIONS AND INSPECTION PROCEDURES. *YC | |
| Bulletin Number: 9922003 | |
| THIS BULLETIN CONTAINS RECOMMENDED MANUAL TRANSMISSION / TRANSAXLE MAINTENANCE INFORMATION. *TT | |
| Bulletin Number: 9923010 | |
| THIS BULLETIN CONTAINS RECOMMENDED AUTOMATIC TRANSMISSION / TRANSAXLE MAINTENANCE INFORMATION. *TT | |
| Bulletin Number: TSB | |
| SERVICE MANUAL REVISION ON CORRECTED AIR CONDITIONER REFRIGERANT. *YC | |
| Bulletin Number: TSB-19-00-008 | |
| This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label. | |
| Bulletin Number: TSB9622005 | |
| ADDITIONAL MANUAL TRANSAXLE SHIFT LEVER OPERATIONAL INSPECTION - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9631003R | |
| 1997 TIRE CHAIN USAGE. *TW | |
| Bulletin Number: TSB9654012 | |
| ANTENNA TIGHTENING TORQUE. *TW | |
| Bulletin Number: TSB9655010 | |
| A/C MICRO SWITCH INSTALLATION INFORMATION. *TW | |
| Bulletin Number: TSB9700005 | |
| MUT-II SCAN TOOL WARRANTY. *TW | |
| Bulletin Number: TSB9711002 | |
| NEW VALVE LASH ADJUSTER NOISE CHECKING AND TROUBLESHOOTING PROCEDURES. *JD | |
| Bulletin Number: TSB9711004 | |
| CRANKSHAFT BEARING SELECTION PROCEDURE - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9711005 | |
| VALVE GUIDE REPLACEMENT PROCEDURES (GALANT) - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9713010 | |
| DTC P0135 INSPECTION PROCEDURE - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9715001 | |
| HESITATION AND/OR SURGE AT HIGHER SPEEDS (4G64 2.4L SOHC ENGINE). *JD | |
| Bulletin Number: TSB9716004 | |
| GENERATOR STATOR REMOVAL - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9723015 | |
| INFORMATION ABOUT IMPROVED AUTOMATIC TRANSAXLE END CLUTCH. *TT | |
| Bulletin Number: TSB9732001 | |
| NOISE DURING GEAR SELECTION OR VIBRATION ON ACCELERATION (UPDATE A/T MOUNT RUBBER STOPPERS). *JD | |
| Bulletin Number: TSB9737A003 | |
| NEW POWER STEERING HOSE - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9742A005 | |
| SUNROOF TRIM COVER LOOSE. *JD | |
| Bulletin Number: TSB9752B002 | |
| ADDITIONAL SRS AIR BAG TROUBLESHOOTING PROCEDURES- SERVICE MANUAL REVISION. *JD | |
| Bulletin Number: TSB9754015 | |
| REPAIR PROCEDURES FOR AUDIO FAILURE ON VARIOUS MODEL YEARS. *YC | |
| Bulletin Number: TSB9755001 | |
| INCORRECT UNDERHOOD AIR CONDITIONER LABEL. *TW | |
| Bulletin Number: TSB9813005 | |
| VEHICLES MAY EXPERIENCE LONG COLD START TIMES, SAG DURING WARM-UP, AND STALLING. *TT | |
| Bulletin Number: TSB9813007 | |
| PROCEDURES ON FULE PUMP OPERATION CHECK. *YC | |
| Bulletin Number: TSB9823007 | |
| THE PARK/NEUTRAL POSITION SWITCH CONTINUITY CHECK TABLE IS INCORRECTLY PRINTED IN THE AFFECTED SERVICE MANUAL PAGES. *YC | |
| Bulletin Number: TSB9823014 | |
| EXPERIENCING A/T HARSH 3-2 DOWNSHIFTS. *TT | |
| Bulletin Number: TSB985001 | |
| SERVICE MANUAL REVISION ON A/C CLUTCH AIR GAP. *YC | |
| Bulletin Number: TT237 | |
| This is a service newsletter (Tech Talk) that was sent out to dealers. | |
| 1997 MITSUBISHI MIRAGE | |
| Bulletin Number: 0013005 | |
| THIS BULLETIN CONTAINS OBD-II DRIVE CYCLE PROCEDURES AND WARRANTY CLAIM INFORMATION FOR OBD-II DRIVE CYCLE ON AFFECTED VEHICLES. *TT | |
| Bulletin Number: 0242A015 | |
| TRUNK LID ADJUSTMENT AND TORSION BAR REMOVAL - SERVICE MANUAL REVISION. *TT | |
| Bulletin Number: 0313005 | |
| OBD-II DRIVE CYCLE. *TT | |
| Bulletin Number: 0323006 | |
| TORQUE CONVERTER SHUDDER, SURGE, AND/OR VIBRATION (POSSIBLY INTERMITTENT) WHEN DRIVING 35-50 MPH AT STEADY THROTTLE. *TT | |
| Bulletin Number: 0513006 | |
| ALTERNATOR FR TERMINAL VOLTAGE - SERVICE MANUAL REVISION. *TT | |
| Bulletin Number: 0523004 | |
| 2-3 SHIFT FLARE. *TT | |
| Bulletin Number: 97090152B003 | |
| SERVICE MANUAL REVISION ON SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CAUTIONS AND WARNINGS. *YC | |
| Bulletin Number: 97090154007 | |
| NEW PROCEDURES FOR ADJUSTING HEADLIGHTS AIM ON VARIOUS VEHICLES. *YC | |
| Bulletin Number: 98070120009 | |
| VEHICLE STALLING ON COLD START-UP. *YC | |
| Bulletin Number: 98070120010 | |
| SEVERAL CASES HAVE BEEN REPORTED OF A RATTLING NOISE FROM AROUND THE MAIN MUFFLER DURING DRIVING. *YC | |
| Bulletin Number: 9813009 | |
| CODE NO. P0340 CAMSHAFT POSITION SENSOR CIRCUIT MALFUNCTION, TROUBLESHOOTING PROCEDURES VOLUME 1 SERVICE MANUALS. YD | |
| Bulletin Number: 9922003 | |
| THIS BULLETIN CONTAINS RECOMMENDED MANUAL TRANSMISSION / TRANSAXLE MAINTENANCE INFORMATION. *TT | |
| Bulletin Number: 9923010 | |
| THIS BULLETIN CONTAINS RECOMMENDED AUTOMATIC TRANSMISSION / TRANSAXLE MAINTENANCE INFORMATION. *TT | |
| Bulletin Number: SR00007 | |
| MITSUBISHI MOTOR SALES OF AMERICA, INC. (MMSA) IS VOLUNTARILY RECALLING AFFECTED VEHICLES FOR A POSSIBLE LOOSE CRANKSHAFT PULLEY BOLT. *TT | |
| Bulletin Number: TSB0013003 | |
| INFORMATION CONTAINING RECOMMENDED FUELS FOR CERTAIN VEHICLES. *TT | |
| Bulletin Number: TSB0042A007 | |
| THIS BULLETIN CONTAINS REVISED DETAILS FOR SUNROOF WATER TEST AND FIT ADJUSTMENT PROCEDURES - SERVICE MANUAL REVISION. *TT | |
| Bulletin Number: TSB0117002 | |
| THIS BULLETIN CONTAINS REVISED CRUISE CONTROL SYSTEM TROUBLESHOOTING PROCEDURES. *TT | |
| Bulletin Number: TSB0123010 | |
| SOME CUSTOMERS MAY COMPLAIN OF SHUDDER, SURGE, AND / OR VIBRATION WHEN DRIVING 35 - 50 MPH AT STEADY THROTTLE. THIS CONDITION MAY BE DUE TO THE BREAKDOWN OF THE SPII A/T FLUID, CREATING A TORQUE CONVERTER DAMPER CLUTCH SHUDDER. | |
| Bulletin Number: TSB0142A001 | |
| INFORMATION ON TRUNK LID RELEASE KITS FOR CONFINEMENT WITHIN TRUNK. *JB | |
| Bulletin Number: TSB0233001 | |
| SUBJECT REGARDING BALL JOINT END PLAY CHECK PROCEDURES - SERVICE MANUAL REVISION. *TT | |
| Bulletin Number: TSB-19-00-008 | |
| This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label. | |
| Bulletin Number: TSB9611012 | |
| ADDITION OF NEW ITEM TO TROUBLESHOOTING CHART (WORN OR DAMAGED VALVE GUIDES) - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9631003R | |
| 1997 TIRE CHAIN USAGE. *TW | |
| Bulletin Number: TSB9700005 | |
| MUT-II SCAN TOOL WARRANTY. *TW | |
| Bulletin Number: TSB9711011 | |
| CONNECTING ROD BEARING IDENTIFICATION COLORS - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9711015 | |
| THROTTLE BODY PROCEDURES (ECLIPSE/ECLIPSE SPYDER, MIRAGE, 3000GT) - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9716005 | |
| IGNITION COIL RESISTANCE - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9726001 | |
| DRIVESHAFT KNOCKING NOISE. *JD | |
| Bulletin Number: TSB9752B002 | |
| ADDITIONAL SRS AIR BAG TROUBLESHOOTING PROCEDURES- SERVICE MANUAL REVISION. *JD | |
| Bulletin Number: TSB9811002 | |
| SERVICE MANUAL REVISION ON CRANKSHAFT PULLEY BOLT TORQUE. *YC | |
| Bulletin Number: TSB9813005 | |
| VEHICLES MAY EXPERIENCE LONG COLD START TIMES, SAG DURING WARM-UP, AND STALLING. *TT | |
| Bulletin Number: TSB985001 | |
| SERVICE MANUAL REVISION ON A/C CLUTCH AIR GAP. *YC | |
| Bulletin Number: TSB9854003 | |
| SERVICE MANUAL REVISION ON CORRECTED COMPONENT GROUNDING LOCATION. *YC | |
| Bulletin Number: TSB9942A008 | |
| SOME VEHICLES (VIN XU046855) EQUIPPED WITH MANUAL WINDOWS MAY EXHIBIT WATER LEAKAGE AND / OR WIND NOISE FROM THE FRONT WINDOW WHEN DRIVING WITH THE WINDOW CLOSED. *TT | |
| Bulletin Number: TT237 | |
| This is a service newsletter (Tech Talk) that was sent out to dealers. | |
| 1997 MITSUBISHI MITSUBISHI | |
| Bulletin Number: 0317005 | |
| SUMMARY OF OBD-II INFORMATION FOR INSPECTION & MAINTENANCE (I/M) PROGRAMS. *TT | |
| Bulletin Number: 48 | |
| SUBJECT REGARDING REMOTE KEYLESS ENTRY (RKE) REMINDER. *TT | |
| Bulletin Number: 97090135004 | |
| INFORMATION ON BRAKE JUDDER DIAGNOSIS AND REPAIR. *YC | |
| Bulletin Number: 97090142A012 | |
| A REPAIR KIT IS NOW AVAILABLE FOR ELIMINATING CERTAIN BUZZ, SQUEAK, AND RATTLE NOISES ON ALL VEHICLES. *YC | |
| Bulletin Number: 97090152B003 | |
| SERVICE MANUAL REVISION ON SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CAUTIONS AND WARNINGS. *YC | |
| Bulletin Number: 97090154011 | |
| MULTI-PURPOSE FUSE CAPACITY IS INCORRECTLY SPECIFIED IN THE AFFECTED SERVICE MANUAL PAGES. *YC | |
| Bulletin Number: 98070120001 | |
| MEDIC SYSTEMS THAT ARE NOT AT DOWNLOAD 89 THERE'S A HOTLINE NUMBER YOU CAN CALL AT ( 714 ) 372-6492. *YC | |
| Bulletin Number: 9942A009 | |
| CONCERNS WITH FRONT DOOR WIND NOISE. *TT | |
| 1997 MITSUBISHI MONTERO | |
| Bulletin Number: 0013005 | |
| THIS BULLETIN CONTAINS OBD-II DRIVE CYCLE PROCEDURES AND WARRANTY CLAIM INFORMATION FOR OBD-II DRIVE CYCLE ON AFFECTED VEHICLES. *TT | |
| Bulletin Number: 0213020 | |
| NEW AND REVISED INFORMATION RELATING TO READINESS TEST STATUS DESCRIPTIONS AND PROCEDURES. *TT | |
| Bulletin Number: 0313005 | |
| OBD-II DRIVE CYCLE. *TT | |
| Bulletin Number: 06012004 | |
| ALARM SOUNDS WHEN UNLOCKING. *EH | |
| Bulletin Number: 97040113003 | |
| MFI TROUBLESHOOTING INFORMATION CONCERNING DTCS P1715 AND P1750. *YC | |
| Bulletin Number: 97040113007 | |
| SPECIFICATIONS FOR AFFECTED VEHICLES. *YC | |
| Bulletin Number: 97040113008 | |
| CONTAINING SCAN TOOL (MUT-II) SAS ADJUSTMENT PROCEDURES FOR EARLY PRODUCTION VEHICLES. *YC | |
| Bulletin Number: 97090122001 | |
| PROCEDURES CONCERNING THE DELETION OF THE OIL GUIDE FROM THE MANUAL TRANSMISSION FOR 1997 MODELS. *YC | |
| Bulletin Number: 97090152B003 | |
| SERVICE MANUAL REVISION ON SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CAUTIONS AND WARNINGS. *YC | |
| Bulletin Number: 97090154009 | |
| INFORMATION CONTAINING A NEW AND REVISED PROCEDURES FOR ADJUSTING HEADLIGHTS AIM ON AFFECTED VEHICLES. *YC | |
| Bulletin Number: 97110151003 | |
| ACCESSORY INSTALLATION FOR THE FRONT FENDER FLARE AND MUDGUARD. *YC | |
| Bulletin Number: 97110154013 | |
| INFORMATION CONTAINING ADDITIONAL GLASS ANTENNA CAUTIONS AND INSPECTION PROCEDURES. *YC | |
| Bulletin Number: 97110155003 | |
| A/C EVAPORATOR REMOVAL AND INSTALLATION PROCEDURES ARE INCORRECTLY SHOWN IN THE AFFECTED SERVICE MANUAL PAGES. *YC | |
| Bulletin Number: 98020131001 | |
| COMPLAINTS OF VIBRATION THROUGHOUT THE VEHICLE NOTICEABLY IN THE DRIVER'S SEAT. *YC | |
| Bulletin Number: 9823005 | |
| DIGANOSIS AND REPAIR PROCEDURES TO ELIMINATE CONDITIONS REGARDING THE MIL ILLUMINATED AND/OR DTC P1715. 96-98 MONTERO AUTOMATIC TRANSMISSIONS MODELS PRODUCED BEFORE 10-97 UP TO VIN WJ003864; 97-98 MONTERO SPORT AUTOMATIC TRANSMISSIONS MO | |
| Bulletin Number: 9823005REV | |
| THE MALFUNCTION INDICATOR LAMP MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE P1715 MAY SET IN THE ENGINE CONTROL MODULE. IN ADDITION, SLUGGISH ACCELERATION WITH THE TRANSMISSION RETURING TO NORMAL SHIFTING AFTER THE IGNITION KEY IS TURNED OFF | |
| Bulletin Number: 9823011 | |
| THIS BULLETIN CONTAINS CORRECTIONS TO THE FORWARD CLUTCH PISTON STROKE SPECIFICATION. *YC | |
| Bulletin Number: 9823012 | |
| PARK/NEUTRAL POSITION SWITCH ADJUSTMENT SERVICE MANUAL REVISION. YD | |
| Bulletin Number: 9823013 | |
| A/T DTCS 29-32 SET CONDITIONS SERVICE MANUAL REVISION. YD | |
| Bulletin Number: 9827001 | |
| PROCEDURES FOR ELIMINATING OR REDUCING AN APPARENT DIFFERENTIAL WHINING NOISE. *YC | |
| Bulletin Number: 9827003 | |
| INFORMATION ABOUT A CHANGE TO THE REAR ROTOR FOR THE ANTI-LOCK BRAKE SYSTEM ( ABS ). *YC 1. 1997 MONTERO BUILT AFTER JUNE 2,1997. 2. 1997 MONTERO SPORT BUILT AFTER JUNE 2,1997. | |
| Bulletin Number: 9851003 | |
| SOME VEHICLES EXPERIENCE PAINT PEELING FROM THE ROOF RACK SURFACE. *YC | |
| Bulletin Number: 9922003 | |
| THIS BULLETIN CONTAINS RECOMMENDED MANUAL TRANSMISSION / TRANSAXLE MAINTENANCE INFORMATION. *TT | |
| Bulletin Number: 9923010 | |
| THIS BULLETIN CONTAINS RECOMMENDED AUTOMATIC TRANSMISSION / TRANSAXLE MAINTENANCE INFORMATION. *TT | |
| Bulletin Number: SR98004 | |
| MITSUBISHI MOTOR SALES OF AMERICA, INC. IS VOLUNTARILY RECALLING CERTAIN VEHICLES TO MODIFY THE REAR CARGO AREA CARPET (MAT). *TT | |
| Bulletin Number: TSB0013003 | |
| INFORMATION CONTAINING RECOMMENDED FUELS FOR CERTAIN VEHICLES. *TT | |
| Bulletin Number: TSB-19-00-008 | |
| This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label. | |
| Bulletin Number: TSB9631003R | |
| 1997 TIRE CHAIN USAGE. *TW | |
| Bulletin Number: TSB9711002 | |
| NEW VALVE LASH ADJUSTER NOISE CHECKING AND TROUBLESHOOTING PROCEDURES. *JD | |
| Bulletin Number: TSB9711004 | |
| CRANKSHAFT BEARING SELECTION PROCEDURE - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9711006 | |
| THROTTLE BODY PROCEDURES - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9711008 | |
| CYLINDER HEAD AND VALVE REMOVAL, INSTALLATION AND INSPECTION CORRECTIONS - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9711009 | |
| CORRECTED UPPER OIL PAN INSTALLATION PROCEDURES - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9711010 | |
| CYLINDER HEAD BOLT INSTALLATION - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9711013 | |
| UPPER OIL PAN INSTALLATION PROCEDURES (MONTERO SPORT) - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9713002 | |
| DELETION OF PRESSURE CONTROL SOLENOID (DTC P1750)- SERVICE MANUAL REVISION. *JD | |
| Bulletin Number: TSB9716004 | |
| GENERATOR STATOR REMOVAL - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9726003 | |
| FRONT ABS SPEED SENSOR ROTOR MODIFICATIONS - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9727001 | |
| VIBRATION AT ACCELERATION- REAR AXLE HOUSING. *JD | |
| Bulletin Number: TSB9735002 | |
| REAR DISC BRAKE CALIPER PROCEDURES - SERVICE MANUAL REVISION. *TW | |
| Bulletin Number: TSB9742A003 | |
| POWER WINDOW MOTOR AND REGULATOR ASSEMBLY PROCEDURES. *JD | |
| Bulletin Number: TSB9742A009 | |
| WIND-RUSH NOISE FROM LEFT SIDE A-PILLAR. *TW | |
| Bulletin Number: TSB9752B002 | |
| ADDITIONAL SRS AIR BAG TROUBLESHOOTING PROCEDURES- SERVICE MANUAL REVISION. *JD | |
| Bulletin Number: TSB9754002 | |
| CORRECTED MOTOR ANTENNA AND CONTROL UNIT INSPECTION PROCEDURES- SERVICE MANUAL REVISION. *JD | |
| Bulletin Number: TSB9813005 | |
| VEHICLES MAY EXPERIENCE LONG COLD START TIMES, SAG DURING WARM-UP, AND STALLING. *TT | |
| Bulletin Number: TSB992700 | |
| CUSTOMER MAY COMPLAIN OF A WHINE COMING FROM THE DIFFERENTIAL. *TT | |
| Bulletin Number: TT237 | |
| This is a service newsletter (Tech Talk) that was sent out to dealers. | |
| 1997 MITSUBISHI MONTERO SPORT | |
| Bulletin Number: 0013005 | |
| THIS BULLETIN CONTAINS OBD-II DRIVE CYCLE PROCEDURES AND WARRANTY CLAIM INFORMATION FOR OBD-II DRIVE CYCLE ON AFFECTED VEHICLES. *TT | |
| Bulletin Number: 0125001 | |
| SUBJECT REGARDING INCORRECT PROPELLER SHAFT INSTALLATION.*JB | |
| Bulletin Number: 0137A003 | |
| SUBJECT REGARDING BALL JOINT DUST COVER GREASE APPLICATION, SERVICE MANUAL REVISION. *SLC | |
| Bulletin Number: 0142A014 | |
| SOME VEHICLES MAY EXPERIENCE VEHICLE BODY VIBRATION.*JB | |
| Bulletin Number: 0213020 | |
| NEW AND REVISED INFORMATION RELATING TO READINESS TEST STATUS DESCRIPTIONS AND PROCEDURES. *TT | |
| Bulletin Number: 0313005 | |
| OBD-II DRIVE CYCLE. *TT | |
| Bulletin Number: 0355001 | |
| A PULSATING OR RATTLE NOISE HEARD WHEN THE AIR CONDITIONER IS ON. *TT | |
| Bulletin Number: 0355004 | |
| AIR CONDITIONER REFRIGERANT QUANTITY - SERVICE MANUAL REVISION. *TT | |
| Bulletin Number: 27 | |
| BRIEF INFORMATION CONCERNING TORQUE CONVERTER VIBRATION / SHUDDER. *TT | |
| Bulletin Number: 27 | |
| BRIEF INFORMATION REGARDING VIBRATION / SHUDDER CONDITION AT REAR OF VEHICLE ON LEAF-SPRING MODELS. *TT | |
| Bulletin Number: 48 | |
| EXHIBITING ROUGH IDLE AFTER WARM-UP. *TT | |
| Bulletin Number: 67 | |
| INFORMATION ON DIAGNOSING TRANSFER LEVER STUCK IN 4H AND TORQUE CONVERTER VIBRATION / SHUDDER / SURGE CONDITION. *TT | |
| Bulletin Number: 67 | |
| SUBJECT REGARDING CRANKSHAFT PULLEY BOLT REPLACEMENT. *JB | |
| Bulletin Number: 7954 | |
| CUSTOMERS MAY REPORT THAT AFTER PUSHING THE HORN BUTTON WHEN THE ACCESSORY SOCKET IS IN USE,THE HORN CONTINUES TO BLOW WHEN THE BUTTON IS RELEASED. *TT | |
| Bulletin Number: 80 | |
| INFORMATION ON A DIAGNOSTIC TROUBLE CODE P0174 SET *TT | |
| Bulletin Number: 8113 | |
| SUBJECT REGARDING DIAGNOSTIC TROUBLE CODES P0171 AND P0174 FOR V6 MODELS. *LC | |
| Bulletin Number: 9722003 | |
| REMOVAL AND INSTALLATION PROCEDURES FOR THE MANUAL TRANSMISSION SHIFT LEVER ARE INCORRECTLY PRINTED. *YC | |
| Bulletin Number: 9751002 | |
| CONDITION WITH LOOSE FITTING REAR FENDER FLARE TRIM. *YC | |
| Bulletin Number: 9752A005 | |
| INFORMATION ON IMPROVED CUP HOLDERS. *YC | |
| Bulletin Number: 9754016 | |
| RATTLE NOISE UNDER INSTRUMENT PANEL. *YC | |
| Bulletin Number: 9811004 | |
| CONDITIONS WITH MIL ON/MISFIRE DTCS/ENGINE KNOCK. *YC | |
| Bulletin Number: 9821001 | |
| THIS BULLETIN CONTAINS THE FOLLOWING ADDITONS, REVISIONS, AND CORRECTIONS RELATED TO THE CLUTCH PEDAL. *YC | |
| Bulletin Number: 9823005 | |
| DIGANOSIS AND REPAIR PROCEDURES TO ELIMINATE CONDITIONS REGARDING THE MIL ILLUMINATED AND/OR DTC P1715. 96-98 MONTERO AUTOMATIC TRANSMISSIONS MODELS PRODUCED BEFORE 10-97 UP TO VIN WJ003864; 97-98 MONTERO SPORT AUTOMATIC TRANSMISSIONS MO | |
| Bulletin Number: 9823005REV | |
| THE MALFUNCTION INDICATOR LAMP MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE P1715 MAY SET IN THE ENGINE CONTROL MODULE. IN ADDITION, SLUGGISH ACCELERATION WITH THE TRANSMISSION RETURING TO NORMAL SHIFTING AFTER THE IGNITION KEY IS TURNED OFF | |
| Bulletin Number: 9823008 | |
| BRIEF INFORMATION ON CORRECTED A/T DIAGNOSTIC PROCEDURES. *YC | |
| Bulletin Number: 9823011 | |
| THIS BULLETIN CONTAINS CORRECTIONS TO THE FORWARD CLUTCH PISTON STROKE SPECIFICATION. *YC | |
| Bulletin Number: 9827003 | |
| INFORMATION ABOUT A CHANGE TO THE REAR ROTOR FOR THE ANTI-LOCK BRAKE SYSTEM ( ABS ). *YC 1. 1997 MONTERO BUILT AFTER JUNE 2,1997. 2. 1997 MONTERO SPORT BUILT AFTER JUNE 2,1997. | |
| Bulletin Number: 9837A001 | |
| SERVICE MANUAL REVISION ON CHANGED TIGHTENING TORQUE SPECIFICATIONS FOR TIE ROD AND RELAY ROD NUTS. *YC | |
| Bulletin Number: 9842A007 | |
| WIND NOISE MAY OCCUR AT THE UPPER FRONT DOOR AREA WHEN DRIVING AT FREEWAY SPEEDS.(1997-99 MONTERO SPORT MODELS PRODUCED BEFORE 8/7/98,UP TO VIN: ---XP0149132). *YC | |
| Bulletin Number: 9922003 | |
| THIS BULLETIN CONTAINS RECOMMENDED MANUAL TRANSMISSION / TRANSAXLE MAINTENANCE INFORMATION. *TT | |
| Bulletin Number: 9923010 | |
| THIS BULLETIN CONTAINS RECOMMENDED AUTOMATIC TRANSMISSION / TRANSAXLE MAINTENANCE INFORMATION. *TT | |
| Bulletin Number: ATIN01SR002 | |
| THIS ADVANCE TECHNICAL INFORMATION NOTICE STATES THAT MITSUBISHI MOTOR SALES OF AMERICA, INC. (MMSA) IS VOLUNTARILY RECALLING AFFECTED VEHICLES FOR A POSSIBLE LOOSE CRANKSHAFT PULLEY BOLT. *TT | |
| Bulletin Number: SR01002 | |
| MITSUBISHI MOTOR SALES OF AMERICA, INC. IS VOLUNTARILY RECALLING CERTAIN AFFECTED VEHICLES FOR A POSSIBLE LOOSE CRANKSHAFT PULLEY BOLT. *TT | |
| Bulletin Number: SR98005 | |
| MITSUBISHI MOTOR SALES OF AMERICA, INC. IS VOLUNTARILY RECALLING CERTAIN VEHICLES FOR INSPECTION AND, IF NECESSARY, REPAIR OF A CONDITION RELATED TO THE FRONT BRAKE TUBES. *TT | |
| Bulletin Number: TIN01SR003 | |
| TECHNICAL INFORMATION REGARDING CRANKSHAFT PULLEY BOLT REPLACEMENT. *TT | |
| Bulletin Number: TSB0011002 | |
| INFORMATION CONTAINING CORRECTED CYLINDER HEAD BOLT TIGHTENING SEQUENCE FOR 2.4L, 4-CYLINDER ENGINES. *TT | |
| Bulletin Number: TSB0013003 | |
| INFORMATION CONTAINING RECOMMENDED FUELS FOR CERTAIN VEHICLES. *TT | |
| Bulletin Number: TSB0023004 | |
| A CONDITION MAY EXIST ON 4-WHEEL-DRIVE MODELS, IF THE DRIVER TRIES TO SHIFT THE TRANSFER LEVER FROM 4L TO 4H WHILE THE VEHICLE IS MOVING, THE LEVER MAY BECOME STUCK IN 4H. SHIFTING FROM 4L TO 4H SHOULD ONLY BE DONE WITH THE VEHICLE S | |
| Bulletin Number: TSB0042A003 | |
| INFORMATION ADDRESSING CUSTOMER BODY VIBRATION COMPLAINTS. *TT | |
| Bulletin Number: TSB0042A005 | |
| CONCERN WITH WINDSHIELD WIND (BUZZ, HUM OR WHISTLE) NOISE, ESPECIALLY IN THE A-PILLAR AREA OR ACROSS THE TOP OF THE WINDSHIELD OCCURING WHEN DRIVING AT HIGHWAY SPEEDS. THE NOISE MAY BE INTERMITTENT, AND TYPICALLY IS MORE EVIDENT AT AMBIE | |
| Bulletin Number: TSB0042A007 | |
| THIS BULLETIN CONTAINS REVISED DETAILS FOR SUNROOF WATER TEST AND FIT ADJUSTMENT PROCEDURES - SERVICE MANUAL REVISION. *TT | |
| Bulletin Number: TSB0055001 | |
| INFORMATION CONCERNING AIR CONDITIONER CONDENSER DAMAGE. *TT | |
| Bulletin Number: TSB0055001R | |
| CONCERNS WITH ROAD DEBRIS (SUCH AS ASPHALT OR SMALL ROCKS) PUSHED INTO THE A/C CONDENSER FAN DURING OPERATION, RESULTING IN INSUFFICIENT OPENING IN THE FAN SHROUD FOR THE DEBRIS TO ESCAPE. *TT | |
| Bulletin Number: TSB0113001 | |
| SUBJECT REGARDING FUEL PUMP OPERATION CHECK - SERVICE MANUAL REVISION. *JB | |
| Bulletin Number: TSB0117003 | |
| THIS BULLETIN PROVIDES CORRECTED INSTRUCTIONS FOR TROUBLESHOOTING CRUISE CONTROL SYSTEM TROUBLE CODE DTC 12, VEHICLE SPEED SENSOR SYSTEM WHICH WAS INCORRECT IN THE SERVICE MANUALS. *TT | |
| Bulletin Number: TSB0123002 | |
| SOME 4-WHEEL DRIVE MODELS MAY EXHIBIT A TRANSFER LEVER STUCK IN 4H. *TT | |
| Bulletin Number: TSB0142A002 | |
| SUBJECT REGARDING CORRECTIONS TO REAR DOOR GLASS HOLDER INSTALLATION INSTRUCTIONS. *JB | |
| Bulletin Number: TSB0142A010 | |
| THIS BULLETIN CONTAINS INSTRUCTIONS FOR ELIMINATING A POPPING NOISE FROM THE REAR HATCH AREA OF THE VEHICLE. *TT | |
| Bulletin Number: TSB0154003 | |
| INFORMATION ON CORRECTIONS TO CIRCUIT DIAGRAMS RELATING TO THE CENTRAL DOOR LOCKING SYSTEM. *JB | |
| Bulletin Number: TSB0211002 | |
| INFORMATION ON CRANKSHAFT IDENTIFICATION MARKS - SERVICE MANUAL REVISION. *TT | |
| Bulletin Number: TSB-19-00-008 | |
| This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label. | |
| Bulletin Number: TSB9752A004 | |
| PROCEDURES FOR REPAIRING LOOSE REAR WHEEL HOUSING CARPET IN THE REAR CARGO AREA. *YC | |
| Bulletin Number: TSB9754015 | |
| REPAIR PROCEDURES FOR AUDIO FAILURE ON VARIOUS MODEL YEARS. *YC | |
| Bulletin Number: TSB9813005 | |
| VEHICLES MAY EXPERIENCE LONG COLD START TIMES, SAG DURING WARM-UP, AND STALLING. *TT | |
| Bulletin Number: TSB985001 | |
| SERVICE MANUAL REVISION ON A/C CLUTCH AIR GAP. *YC | |
| Bulletin Number: TSB9914001 | |
| INFORMATION REGARDING RADIATOR FAN SHROUD BREAKAGE. *TT | |
| Bulletin Number: TSB9942A010 | |
| THIS BULLETIN CONTAINS INFORMATION ABOUT A NEW STRONGER REAR LIFTGATE GAS SPRING. THIS NEW SPRING IS BEING INTRODUCED TO ELIMINATE A CONDITION WHERE THE GAS SPRINGS MAY NOT ALLOW THE REAR LIFTGATE TO OPEN SATISFACTORILY. *TT | |
| Bulletin Number: TT237 | |
| This is a service newsletter (Tech Talk) that was sent out to dealers. | |
| 1997 MITSUBISHI FUSO FE | |
| Bulletin Number: 97008 | |
| CHANGE IN DIMENSIONS OF TRANSMISSION SHIFT FORKS AND SPRING PIN. *YC | |
| Bulletin Number: TSB-19-00-008 | |
| This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label. | |
| Bulletin Number: TT237 | |
| This is a service newsletter (Tech Talk) that was sent out to dealers. | |
| 1997 MITSUBISHI FUSO FE6 | |
| Bulletin Number: 00003 | |
| MFTA HAS MADE AVAILABLE AN EXTERNAL OIL FILTER KIT FOR THE AUTOMATIC TRANSMISSION USED IN THE FE SERIES TRUCKS. USE OF THIS FILTER KIT MAY HELP EXTEND THE LIFE OF THE FE SERIES TRANSMISSION IN A NUMBER OF AREAS. *TT | |
| Bulletin Number: 98-001 | |
| SUBJECT ON IDLER GEAR REPLACEMENT. *YC | |
| Bulletin Number: 98001 | |
| SUBJECT ON IDLER GEAR REPLACEMENT UNDER PRODUCT IMPROVEMENT CAMPAIGN SKTVY220. *YC | |
| Bulletin Number: 98010 | |
| COMPLAINTS OF LOOSE WEATHERSTRIPING AROUND CAB DOOR AREA. *YC | |
| Bulletin Number: 980501 | |
| INFORMATION REGARDING ENGINE IDLER GEAR. *YC | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FE639 | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FE640 | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FE649 | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FG | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FG6 | |
| Bulletin Number: 98010 | |
| COMPLAINTS OF LOOSE WEATHERSTRIPING AROUND CAB DOOR AREA. *YC | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FG639 | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FG649 | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FH | |
| Bulletin Number: 97001 | |
| ON FH, FK AND FM MODELS THE SHIFT FORK ROLL PIN HAVE BEEN MODIFIED FROM SINGLE TO DOUBLE ROLL IN CYLINDRICAL MANUAL TRANSMISSION. *YC | |
| Bulletin Number: 97002 | |
| INFORMATION ON ESTABLISHING COMMON USE OF SYNCHRONIZER PARTS IN MANUAL TRANSMISSION ON FH, FK AND FM MODELS. *YC | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| Bulletin Number: TSB-19-00-008 | |
| This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label. | |
| Bulletin Number: TT237 | |
| This is a service newsletter (Tech Talk) that was sent out to dealers. | |
| 1997 MITSUBISHI FUSO FH2 | |
| Bulletin Number: 98010 | |
| COMPLAINTS OF LOOSE WEATHERSTRIPING AROUND CAB DOOR AREA. *YC | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FH210 | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FH211 | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FK | |
| Bulletin Number: 97001 | |
| ON FH, FK AND FM MODELS THE SHIFT FORK ROLL PIN HAVE BEEN MODIFIED FROM SINGLE TO DOUBLE ROLL IN CYLINDRICAL MANUAL TRANSMISSION. *YC | |
| Bulletin Number: 97002 | |
| INFORMATION ON ESTABLISHING COMMON USE OF SYNCHRONIZER PARTS IN MANUAL TRANSMISSION ON FH, FK AND FM MODELS. *YC | |
| 1997 MITSUBISHI FUSO FK617 | |
| Bulletin Number: 1002710 | |
| ASHTRAY IS COMPRISED OF MATERIAL OF INSUFFICIENT DURABILITY. INVOLVES CERTAIN 1996-2002 MODEL YEAR FK617, FM617 & FM657 TRUCKS PRODUCED FROM JAN. 20, 1995 THROUGH FEB. 27, 2002. *NJ | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FK61F | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FM | |
| Bulletin Number: 97001 | |
| ON FH, FK AND FM MODELS THE SHIFT FORK ROLL PIN HAVE BEEN MODIFIED FROM SINGLE TO DOUBLE ROLL IN CYLINDRICAL MANUAL TRANSMISSION. *YC | |
| Bulletin Number: 97002 | |
| INFORMATION ON ESTABLISHING COMMON USE OF SYNCHRONIZER PARTS IN MANUAL TRANSMISSION ON FH, FK AND FM MODELS. *YC | |
| Bulletin Number: TSB-19-00-008 | |
| This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label. | |
| Bulletin Number: TT237 | |
| This is a service newsletter (Tech Talk) that was sent out to dealers. | |
| 1997 MITSUBISHI FUSO FM617 | |
| Bulletin Number: 1002710 | |
| ASHTRAY IS COMPRISED OF MATERIAL OF INSUFFICIENT DURABILITY. INVOLVES CERTAIN 1996-2002 MODEL YEAR FK617, FM617 & FM657 TRUCKS PRODUCED FROM JAN. 20, 1995 THROUGH FEB. 27, 2002. *NJ | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FM61F | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FM64F | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FM657 | |
| Bulletin Number: 1002710 | |
| ASHTRAY IS COMPRISED OF MATERIAL OF INSUFFICIENT DURABILITY. INVOLVES CERTAIN 1996-2002 MODEL YEAR FK617, FM617 & FM657 TRUCKS PRODUCED FROM JAN. 20, 1995 THROUGH FEB. 27, 2002. *NJ | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FM65F | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FN4 | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FP4 | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FR5 | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FS4 | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FT4 | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FU4 | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
| 1997 MITSUBISHI FUSO FV4 | |
| Bulletin Number: SC-C-0040690 | |
| MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER | |
Recalls for 1997 Mitsubishi
| 1997 MITSUBISHI 3000GT | |
|---|---|
| NHTSA Campaign ID: | POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) |
| Manufacturer: | MITSUBISHI AMERICA |
| Manufacture Dates: | - |
| Potential Units Affected: | 15000 |
Defect Description:ON CERTAIN PASSENGER VEHICLES, A CONDITION EXISTS THAT ALLOWS OIL TO LEAK FROM THE ALL-WHEEL DRIVE TRANSFER CASE. Consequence:LOW OIL LEVELS IN THE TRANSFER CASE COULD CAUSE BEARING DAMAGE AND RESULT IN DRIVE TRAIN LOCKUP, INCREASING THE RISK OF A CRASH. Action:DEALERS WILL INSPECT THE TRANSFER CASE FOR INDICATIONS OF OIL LEAKAGE OR DAMAGE. VEHICLES THAT HAVE OIL LEAKAGE WILL HAVE THE TRANSFER CASE RESEALED AND RE-FILL THE TRANSFER CASE TO THE PROPER LEVEL, OR REPLACED THE TRANSFER CASE IF THERE IS EVIDENCE OF DAMAGE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DECEMBER 9, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AMERICA AT 1-888-648-7820 OR MITSUBMISHI CARIBBEAN AT 1-787-251-8715. | |
| 1997 MITSUBISHI ECLIPSE | |
|---|---|
| NHTSA Campaign ID: | SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT |
| Manufacturer: | MITSUBISHI AMERICA |
| Manufacture Dates: | 03/01/1994 - 06/30/1999 |
| Potential Units Affected: | 567432 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE. Consequence:THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066. Action:DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE. | |
| 1997 MITSUBISHI ECLIPSE | |
|---|---|
| NHTSA Campaign ID: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturer: | MITSUBISHI AMERICA |
| Manufacture Dates: | 05/15/1989 - 03/06/1998 |
| Potential Units Affected: | 24275 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER VEHICLES. LOCKUP OF THE TRANSFER CASE CAN OCCUR DUE TO INSUFFICIENT LUBRICATION. Consequence:THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH. Action:DEALERS WILL INSPECT THE VEHICLES FOR ADEQUACY OF THE TRANSFER CASE OIL VOLUME, TRANSFER CASE OIL LEAKAGE, AND OPERATIONAL DEGRADATION OF THE TRANSFER CASE MECHANISM. IF OIL VOLUME IS INSUFFICIENT, THE APPROPRIATE AMOUNT OF OIL WILL BE ADDED. IF THERE IS TRANSFER CASE OIL LEAKAGE, AFFECTED COMPONENTS WILL BE REPLACED. IF THE TRANSFER CASE SHOWS OPERATIONAL DEGRADATION, THE TRANSFER CASE WILL BE REPLACED. | |
| 1997 MITSUBISHI ECLIPSE | |
|---|---|
| NHTSA Campaign ID: | SEATS:FRONT ASSEMBLY:HEAD RESTRAINT |
| Manufacturer: | MITSUBISHI AMERICA |
| Manufacture Dates: | 03/18/1997 - 03/26/1997 |
| Potential Units Affected: | 119 |
Defect Description:THE HEADREST GUIDE BRACKET WAS IMPROPERLY WELDED TO THE SEAT BACK FRAME ON THE PASSENGER SIDE SEAT BACK ASSEMBLIES ONLY. Consequence:THE HEADREST SUPPORT BRACKET CAN BREAK, INCREASING THE RISK OF PERSONAL INJURY. Action:DEALERS WILL REPLACE THE PASSENGER SEAT BACK ASSEMBLY WITH A NEW ASSEMBLY. | |
| 1997 MITSUBISHI ECLIPSE SPYDER | |
|---|---|
| NHTSA Campaign ID: | SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT |
| Manufacturer: | MITSUBISHI AMERICA |
| Manufacture Dates: | 12/01/1995 - 06/30/1999 |
| Potential Units Affected: | 567432 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE. Consequence:THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066. Action:DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE. | |
| 1997 MITSUBISHI GALANT | |
|---|---|
| NHTSA Campaign ID: | SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT |
| Manufacturer: | MITSUBISHI AMERICA |
| Manufacture Dates: | 02/01/1993 - 06/30/1999 |
| Potential Units Affected: | 567432 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE. Consequence:THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066. Action:DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE. | |
| 1997 MITSUBISHI MIRAGE | |
|---|---|
| NHTSA Campaign ID: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturer: | MITSUBISHI AMERICA |
| Manufacture Dates: | 03/01/1996 - 02/28/1999 |
| Potential Units Affected: | 210000 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER VEHICLES: MIRAGE MODEL VEHICLES EQUIPPED WITH 1.5L ENGINES; MONTERO SPORT MODELS EQUIPPED WITH 3.0L ENGINES; AND MONTERO MODELS EQUIPPED WITH 3.0L ENGINES. THE BOLT SECURING THE CRANKSHAFT PULLEY CAN BECOME LOOSE AND THE PULLEY COULD FALL OFF THE VEHICLE. Consequence:THE CONDITION CAN RESULT IN A LOSS OF POWER STEERING ASSIST, INCREASING THE RISK OF A CRASH. Action:ON THE MIRAGE VEHICLES, THE DEALERS WILL INSTALL A NEW, IMPROVED CRANKSHAFT PULLEY BOLT ON THE OLDER ENGINES. ON NEW ENGINES WHICH ALREADY HAVE THE IMPROVED BOLT, THE DEALER WILL TIGHTEN THE CRANKSHAFT PULLEY BOLT TO THE CORRECT TORQUE SPECIFICATION. ON THE MONTERO MODELS, DEALERS WILL TIGHTEN THE CRANKSHAFT PULLEY BOLT TO THE CORRECT TORQUE SPECIFICATIONS. IF THE BOLT IS DAMAGED, IT WILL BE REPLACED. | |
| 1997 MITSUBISHI MONTERO | |
|---|---|
| NHTSA Campaign ID: | UNKNOWN OR OTHER |
| Manufacturer: | MITSUBISHI AMERICA |
| Manufacture Dates: | 07/01/1993 - 06/30/1998 |
| Potential Units Affected: | 60243 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ACCESSORY CARGO MATS IN THE THIRD-SEAT AND CARGO AREA. THIS CARGO MAT INTERFERES WITH THE LATCHING INTEGRITY OF THE FOLDING THIRD SEATS. Consequence:IN THE EVENT OF A CRASH, AN OCCUPANT OF THE THIRD SEAT MAY NOT BE PROPERLY RESTRAINED AND COULD BE EJECTED FROM THE VEHICLE. Action:DEALERS WILL INSPECT THE THIRD-SEAT LATCH AND STRIKER. A RECTANGLE WILL BE REMOVED FROM THE CARGO MAT AROUND EACH STRIKER TO PROVIDE ADEQUATE STRIKER CLEARANCE AND PROPER LATCHING. | |
| 1997 MITSUBISHI MONTERO | |
|---|---|
| NHTSA Campaign ID: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturer: | MITSUBISHI AMERICA |
| Manufacture Dates: | 06/17/1996 - 05/18/1998 |
| Potential Units Affected: | 61800 |
Defect Description:VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FRONT BRAKE LINES CAN DEVELOP PIN HOLES DUE TO CHAFFING AGAINST THE EDGE OF THE PASS-THROUGH HOLE IN THE INNER FENDER. Consequence:BRAKE FLUID CAN LEAK RESULTING IN DETERIORATED BRAKING PERFORMANCE AND ILLUMINATION OF THE BRAKE INDICATOR LAMP. Action:DEALERS WILL INSPECT THE FRONT BRAKE LINES FOR SIGNS OF WEAR AND ROUTING. IF THE LINES ARE NOT CORRECTLY CENTERED IN THE PASS-THROUGH HOLE, THE LINES WILL BE REPOSITIONED BY BENDING SLIGHTLY TO CORRECT. IF THERE IS EVIDENCE OF BRAKE LINE WEAR, THE BRAKE LINE WILL BE REPLACED. | |
| 1997 MITSUBISHI MONTERO SPORT | |
|---|---|
| NHTSA Campaign ID: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturer: | MITSUBISHI AMERICA |
| Manufacture Dates: | 08/01/1996 - 03/31/1999 |
| Potential Units Affected: | 210000 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER VEHICLES: MIRAGE MODEL VEHICLES EQUIPPED WITH 1.5L ENGINES; MONTERO SPORT MODELS EQUIPPED WITH 3.0L ENGINES; AND MONTERO MODELS EQUIPPED WITH 3.0L ENGINES. THE BOLT SECURING THE CRANKSHAFT PULLEY CAN BECOME LOOSE AND THE PULLEY COULD FALL OFF THE VEHICLE. Consequence:THE CONDITION CAN RESULT IN A LOSS OF POWER STEERING ASSIST, INCREASING THE RISK OF A CRASH. Action:ON THE MIRAGE VEHICLES, THE DEALERS WILL INSTALL A NEW, IMPROVED CRANKSHAFT PULLEY BOLT ON THE OLDER ENGINES. ON NEW ENGINES WHICH ALREADY HAVE THE IMPROVED BOLT, THE DEALER WILL TIGHTEN THE CRANKSHAFT PULLEY BOLT TO THE CORRECT TORQUE SPECIFICATION. ON THE MONTERO MODELS, DEALERS WILL TIGHTEN THE CRANKSHAFT PULLEY BOLT TO THE CORRECT TORQUE SPECIFICATIONS. IF THE BOLT IS DAMAGED, IT WILL BE REPLACED. | |
| 1997 MITSUBISHI NATIVA | |
|---|---|
| NHTSA Campaign ID: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturer: | MITSUBISHI CARIBBEAN |
| Manufacture Dates: | 08/01/1996 - 03/31/1999 |
| Potential Units Affected: | 61068 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE BOLT SECURING THE CRANKSHAFT PULLEY CAN BECOME LOOSE AND THE PULLEY COULD FALL OFF THE VEHICLE. Consequence:THE CONDITION CAN RESULT IN A LOSS OF POWER STEERING ASSIST, INCREASING THE RISK OF A CRASH. Action:ON THE MIRAGE VEHICLES, THE DEALERS WILL INSTALL A NEW, IMPROVED CRANKSHAFT PULLEY BOLT ON THE OLDER ENGINES. ON NEW ENGINES WHICH ALREADY HAVE THE IMPROVED BOLT, THE DEALER WILL TIGHTEN THE CRANKSHAFT PULLEY BOLT TO THE CORRECT TORQUE SPECIFICATION. ON THE MONTERO MODELS, DEALERS WILL TIGHTEN THE CRANKSHAFT PULLEY BOLT TO THE CORRECT TORQUE SPECIFICATIONS. IF THE BOLT IS DAMAGED, IT WILL BE REPLACED. | |
| 1997 MITSUBISHI NATIVA | |
|---|---|
| NHTSA Campaign ID: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturer: | MITSUBISHI CARIBBEAN |
| Manufacture Dates: | 06/17/1996 - 05/18/1998 |
| Potential Units Affected: | 6609 |
Defect Description:VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FRONT BRAKE LINES CAN DEVELOP PIN HOLES DUE TO CHAFFING AGAINST THE EDGE OF THE PASS-THROUGH HOLE IN THE INNER FENDER. Consequence:BRAKE FLUID CAN LEAK RESULTING IN DETERIORATED BRAKING PERFORMANCE AND ILLUMINATION OF THE BRAKE INDICATOR LAMP. Action:DEALERS WILL INSPECT THE FRONT BRAKE LINES FOR SIGNS OF WEAR AND ROUTING. IF THE LINES ARE NOT CORRECTLY CENTERED IN THE PASS-THROUGH HOLE, THE LINES WILL BE REPOSITIONED BY BENDING SLIGHTLY TO CORRECT. IF THERE IS EVIDENCE OF BRAKE LINE WEAR, THE BRAKE LINE WILL BE REPLACED. | |
| 1997 MITSUBISHI CARIBBEAN ECLIPSE | |
|---|---|
| NHTSA Campaign ID: | SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT |
| Manufacturer: | MITSUBISHI CARIBBEAN |
| Manufacture Dates: | 03/01/1994 - 06/30/1999 |
| Potential Units Affected: | 5164 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE. Consequence:THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066. Action:DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE. | |
| 1997 MITSUBISHI CARIBBEAN ECLIPSE SPYDER | |
|---|---|
| NHTSA Campaign ID: | SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT |
| Manufacturer: | MITSUBISHI CARIBBEAN |
| Manufacture Dates: | 12/01/1995 - 06/30/1999 |
| Potential Units Affected: | 5164 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE. Consequence:THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066. Action:DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE. | |
| 1997 MITSUBISHI CARIBBEAN GALANT | |
|---|---|
| NHTSA Campaign ID: | SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT |
| Manufacturer: | MITSUBISHI CARIBBEAN |
| Manufacture Dates: | 02/01/1993 - 03/31/1998 |
| Potential Units Affected: | 5164 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE. Consequence:THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066. Action:DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE. | |
| 1997 MITSUBISHI CARIBBEAN MIRAGE | |
|---|---|
| NHTSA Campaign ID: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturer: | MITSUBISHI CARIBBEAN |
| Manufacture Dates: | 03/01/1996 - 02/28/1999 |
| Potential Units Affected: | 61068 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE BOLT SECURING THE CRANKSHAFT PULLEY CAN BECOME LOOSE AND THE PULLEY COULD FALL OFF THE VEHICLE. Consequence:THE CONDITION CAN RESULT IN A LOSS OF POWER STEERING ASSIST, INCREASING THE RISK OF A CRASH. Action:ON THE MIRAGE VEHICLES, THE DEALERS WILL INSTALL A NEW, IMPROVED CRANKSHAFT PULLEY BOLT ON THE OLDER ENGINES. ON NEW ENGINES WHICH ALREADY HAVE THE IMPROVED BOLT, THE DEALER WILL TIGHTEN THE CRANKSHAFT PULLEY BOLT TO THE CORRECT TORQUE SPECIFICATION. ON THE MONTERO MODELS, DEALERS WILL TIGHTEN THE CRANKSHAFT PULLEY BOLT TO THE CORRECT TORQUE SPECIFICATIONS. IF THE BOLT IS DAMAGED, IT WILL BE REPLACED. | |
| 1997 MITSUBISHI CARIBBEAN MONTERO | |
|---|---|
| NHTSA Campaign ID: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturer: | MITSUBISHI CARIBBEAN |
| Manufacture Dates: | 01/01/1991 - 03/31/1999 |
| Potential Units Affected: | 61068 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE BOLT SECURING THE CRANKSHAFT PULLEY CAN BECOME LOOSE AND THE PULLEY COULD FALL OFF THE VEHICLE. Consequence:THE CONDITION CAN RESULT IN A LOSS OF POWER STEERING ASSIST, INCREASING THE RISK OF A CRASH. Action:ON THE MIRAGE VEHICLES, THE DEALERS WILL INSTALL A NEW, IMPROVED CRANKSHAFT PULLEY BOLT ON THE OLDER ENGINES. ON NEW ENGINES WHICH ALREADY HAVE THE IMPROVED BOLT, THE DEALER WILL TIGHTEN THE CRANKSHAFT PULLEY BOLT TO THE CORRECT TORQUE SPECIFICATION. ON THE MONTERO MODELS, DEALERS WILL TIGHTEN THE CRANKSHAFT PULLEY BOLT TO THE CORRECT TORQUE SPECIFICATIONS. IF THE BOLT IS DAMAGED, IT WILL BE REPLACED. | |
| 1997 MITSUBISHI FUSO FE639 | |
|---|---|
| NHTSA Campaign ID: | PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE |
| Manufacturer: | MITSUBISHI FUSO TRUCK OF AMERICA, INC. |
| Manufacture Dates: | 02/21/1995 - 03/29/2001 |
| Potential Units Affected: | 18094 |
Defect Description:ON CERTAIN TRUCKS, THE CABLE END OF THE PARKING BRAKE CABLE, WHERE IT ATTACHES TO THE PARKING BRAKE LEVER, IS DESIGNED IMPROPERLY. REPEATED NORMAL PARKING BRAKE OPERATION MAY CAUSE THE CABLE END TO BECOME IMPROPERLY SEATED IN THE PARKING BRAKE LEVER GROOVE. Consequence:IN THIS CONDITION, THE PARKING BRAKE CABLE MAY BEND AND BREAK DUE TO FATIGUE. THE PARKING BRAKE MAY BECOME INOPERATIVE AND THE TRUCK MAY ROLL AND CAUSE A CRASH, PROPERTY AND PERSONAL INJURIES. Action:DEALERS WILL INSPECT THE PARKING BRAKE CABLE FOR BENDING OR DAMAGE AT THE CABLE END AND INSTALL A MODIFIED PARKING BRAKE CABLE ASSEMBLY IF THE CABLE IS BENT OR DAMAGED AT THE CABLE END. IF NO BENDING OR DAMAGE EXISTS, DEALERS WILL INSTALL A CABLE RETAINER ON THE CABLE END OF THE PARKING BRAKE CABLE. THE RECALL BEGAN ON JANUARY 13, 2005. OWNERS SHOULD CONTACT MITSUBISHI FUSO AT 1-877-711-0707. | |
| 1997 MITSUBISHI FUSO FE639 | |
|---|---|
| NHTSA Campaign ID: | SUSPENSION:FRONT:CONTROL ARM |
| Manufacturer: | MITSUBISHI FUSO TRUCK OF AMERICA, INC. |
| Manufacture Dates: | 02/21/1995 - 11/06/1998 |
| Potential Units Affected: | 10333 |
Defect Description:ON CERTAIN TRUCKS, THE TIE ROD END BALL JOINT DUST BOOT WAS DESIGNED WITH INSUFFICIENT SEALING ABILITY. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER INTO THE TIE ROD END BALL JOINT, ABNORMALLY WEARING THE RESIN BEARING LOCATED INSIDE THE JOINT. Consequence:THE TIE ROD END BALL JOINT COULD SEPARATE FROM THE TIE ROD END, DISABLING THE STEERING SYSTEM, AND CAUSING A CRASH . Action:DEALERS WILL INSTALL MODIFIED TIE ROD END ASSEMBLIES. THE RECALL BEGAN ON JANUARY 13, 2005. OWNERS SHOULD CONTACT MITSUBISHI FUSO AT 856-467-3917. | |
| 1997 MITSUBISHI FUSO FE649 | |
|---|---|
| NHTSA Campaign ID: | PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE |
| Manufacturer: | MITSUBISHI FUSO TRUCK OF AMERICA, INC. |
| Manufacture Dates: | 02/21/1995 - 02/22/2001 |
| Potential Units Affected: | 18094 |
Defect Description:ON CERTAIN TRUCKS, THE CABLE END OF THE PARKING BRAKE CABLE, WHERE IT ATTACHES TO THE PARKING BRAKE LEVER, IS DESIGNED IMPROPERLY. REPEATED NORMAL PARKING BRAKE OPERATION MAY CAUSE THE CABLE END TO BECOME IMPROPERLY SEATED IN THE PARKING BRAKE LEVER GROOVE. Consequence:IN THIS CONDITION, THE PARKING BRAKE CABLE MAY BEND AND BREAK DUE TO FATIGUE. THE PARKING BRAKE MAY BECOME INOPERATIVE AND THE TRUCK MAY ROLL AND CAUSE A CRASH, PROPERTY AND PERSONAL INJURIES. Action:DEALERS WILL INSPECT THE PARKING BRAKE CABLE FOR BENDING OR DAMAGE AT THE CABLE END AND INSTALL A MODIFIED PARKING BRAKE CABLE ASSEMBLY IF THE CABLE IS BENT OR DAMAGED AT THE CABLE END. IF NO BENDING OR DAMAGE EXISTS, DEALERS WILL INSTALL A CABLE RETAINER ON THE CABLE END OF THE PARKING BRAKE CABLE. THE RECALL BEGAN ON JANUARY 13, 2005. OWNERS SHOULD CONTACT MITSUBISHI FUSO AT 1-877-711-0707. | |
| 1997 MITSUBISHI FUSO FE649 | |
|---|---|
| NHTSA Campaign ID: | SUSPENSION:FRONT:CONTROL ARM |
| Manufacturer: | MITSUBISHI FUSO TRUCK OF AMERICA, INC. |
| Manufacture Dates: | 02/21/1995 - 11/06/1998 |
| Potential Units Affected: | 10333 |
Defect Description:ON CERTAIN TRUCKS, THE TIE ROD END BALL JOINT DUST BOOT WAS DESIGNED WITH INSUFFICIENT SEALING ABILITY. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER INTO THE TIE ROD END BALL JOINT, ABNORMALLY WEARING THE RESIN BEARING LOCATED INSIDE THE JOINT. Consequence:THE TIE ROD END BALL JOINT COULD SEPARATE FROM THE TIE ROD END, DISABLING THE STEERING SYSTEM, AND CAUSING A CRASH . Action:DEALERS WILL INSTALL MODIFIED TIE ROD END ASSEMBLIES. THE RECALL BEGAN ON JANUARY 13, 2005. OWNERS SHOULD CONTACT MITSUBISHI FUSO AT 856-467-3917. | |
| 1997 MITSUBISHI FUSO FK617 | |
|---|---|
| NHTSA Campaign ID: | STRUCTURE:BODY |
| Manufacturer: | MITSUBISHI FUSO TRUCK OF AMERICA, INC. |
| Manufacture Dates: | 04/10/1995 - 11/19/1998 |
| Potential Units Affected: | 2609 |
Defect Description:ON CERTAIN TRUCKS, THE CLEARANCE BETWEEN THE CAB MAIN HOOK AND THE SURROUNDING COMPONENTS MAY BE INSUFFICIENT. REPEATED NORMAL CAB TILTING OPERATION COULD CAUSE THE CAB TILT SYSTEM COMPONENTS TO BECOME DAMAGED IN THE AREA OF THE CAB MAIN HOOK. Consequence:IF DAMAGE OCCURS, THE CAB MAIN HOOK COULD LATCH IMPROPERLY, AND IN THE WORST CASE, THE CAB COULD TILT FORWARD DURING NORMAL VEHICLE OPERATION. A CRASH COULD OCCUR WITHOUT PRIOR WARNING. Action:DEALERS WILL REPLACE THE CAB HOOK, LOCK LEVER AND CONTROL LEVER BRACKET WITH MODIFIED COMPONENTS. THE RECALL BEGAN ON OCTOBER 28, 2004. OWNERS SHOULD CONTACT MITSUBISHI FUSO AT 1-877-711-0707. | |
| 1997 MITSUBISHI FUSO FK617 | |
|---|---|
| NHTSA Campaign ID: | INTERIOR LIGHTING |
| Manufacturer: | MITSUBISHI FUSO TRUCK OF AMERICA, INC. |
| Manufacture Dates: | 04/14/1995 - 12/23/2003 |
| Potential Units Affected: | 16101 |
Defect Description:ON CERTAIN TRUCKS, THE REBOUND CUSHION MAY STICK TO THE HOOK HINGE BRACKET, DUE TO IMPROPER RUBBER COMPOSITION OF THE CUSHION. THIS CONDITION COULD RESULT IN THE HOOK PIN BRACKET REMAINING IN THE UP (CAB CLOSED) POSITION WHEN THE CAB LATCH IS UNLOCKED. WITH THE HOOK PIN BRACKET IN THE UP POSITION, THE CAB TILT LOCK SWITCH REMAINS CLOSED, IMPROPERLY INDICATING THAT THE CAB LATCH IS LOCKED. Consequence:IF THE CAB LATCH IS UNLOCKED FOR ANY REASON, THE INSTRUMENT PANEL CAB LOCK INDICATOR WILL NOT NOTIFY THE DRIVER THAT THE CAB TILT LOCK MECHANISM IS IN THE UNLOCKED POSITION. A CRASH COULD OCCUR WITHOUT PRIOR WARNING. Action:DEALERS WILL REPLACE THE REBOUND CUSHION WITH A MODIFIED COMPONENT AND ADJUST THE CABLE TILT LOCK SWITCH AND BOTTOM BRACKET AT THE REAR CAB MOUNT. THE RECALL BEGAN ON OCTOBER 28, 2004. OWNERS SHOULD CONTACT MITSUBISHI FUSO AT 1-877-711-0707. | |
| 1997 MITSUBISHI FUSO FM617 | |
|---|---|
| NHTSA Campaign ID: | INTERIOR LIGHTING |
| Manufacturer: | MITSUBISHI FUSO TRUCK OF AMERICA, INC. |
| Manufacture Dates: | 04/14/1995 - 01/12/2004 |
| Potential Units Affected: | 16101 |
Defect Description:ON CERTAIN TRUCKS, THE REBOUND CUSHION MAY STICK TO THE HOOK HINGE BRACKET, DUE TO IMPROPER RUBBER COMPOSITION OF THE CUSHION. THIS CONDITION COULD RESULT IN THE HOOK PIN BRACKET REMAINING IN THE UP (CAB CLOSED) POSITION WHEN THE CAB LATCH IS UNLOCKED. WITH THE HOOK PIN BRACKET IN THE UP POSITION, THE CAB TILT LOCK SWITCH REMAINS CLOSED, IMPROPERLY INDICATING THAT THE CAB LATCH IS LOCKED. Consequence:IF THE CAB LATCH IS UNLOCKED FOR ANY REASON, THE INSTRUMENT PANEL CAB LOCK INDICATOR WILL NOT NOTIFY THE DRIVER THAT THE CAB TILT LOCK MECHANISM IS IN THE UNLOCKED POSITION. A CRASH COULD OCCUR WITHOUT PRIOR WARNING. Action:DEALERS WILL REPLACE THE REBOUND CUSHION WITH A MODIFIED COMPONENT AND ADJUST THE CABLE TILT LOCK SWITCH AND BOTTOM BRACKET AT THE REAR CAB MOUNT. THE RECALL BEGAN ON OCTOBER 28, 2004. OWNERS SHOULD CONTACT MITSUBISHI FUSO AT 1-877-711-0707. | |
| 1997 MITSUBISHI FUSO FM617 | |
|---|---|
| NHTSA Campaign ID: | STRUCTURE:BODY |
| Manufacturer: | MITSUBISHI FUSO TRUCK OF AMERICA, INC. |
| Manufacture Dates: | 04/10/1995 - 10/27/1998 |
| Potential Units Affected: | 2609 |
Defect Description:ON CERTAIN TRUCKS, THE CLEARANCE BETWEEN THE CAB MAIN HOOK AND THE SURROUNDING COMPONENTS MAY BE INSUFFICIENT. REPEATED NORMAL CAB TILTING OPERATION COULD CAUSE THE CAB TILT SYSTEM COMPONENTS TO BECOME DAMAGED IN THE AREA OF THE CAB MAIN HOOK. Consequence:IF DAMAGE OCCURS, THE CAB MAIN HOOK COULD LATCH IMPROPERLY, AND IN THE WORST CASE, THE CAB COULD TILT FORWARD DURING NORMAL VEHICLE OPERATION. A CRASH COULD OCCUR WITHOUT PRIOR WARNING. Action:DEALERS WILL REPLACE THE CAB HOOK, LOCK LEVER AND CONTROL LEVER BRACKET WITH MODIFIED COMPONENTS. THE RECALL BEGAN ON OCTOBER 28, 2004. OWNERS SHOULD CONTACT MITSUBISHI FUSO AT 1-877-711-0707. | |
| 1997 MITSUBISHI FUSO FM657 | |
|---|---|
| NHTSA Campaign ID: | STRUCTURE:BODY |
| Manufacturer: | MITSUBISHI FUSO TRUCK OF AMERICA, INC. |
| Manufacture Dates: | 04/10/1995 - 09/22/1998 |
| Potential Units Affected: | 2609 |
Defect Description:ON CERTAIN TRUCKS, THE CLEARANCE BETWEEN THE CAB MAIN HOOK AND THE SURROUNDING COMPONENTS MAY BE INSUFFICIENT. REPEATED NORMAL CAB TILTING OPERATION COULD CAUSE THE CAB TILT SYSTEM COMPONENTS TO BECOME DAMAGED IN THE AREA OF THE CAB MAIN HOOK. Consequence:IF DAMAGE OCCURS, THE CAB MAIN HOOK COULD LATCH IMPROPERLY, AND IN THE WORST CASE, THE CAB COULD TILT FORWARD DURING NORMAL VEHICLE OPERATION. A CRASH COULD OCCUR WITHOUT PRIOR WARNING. Action:DEALERS WILL REPLACE THE CAB HOOK, LOCK LEVER AND CONTROL LEVER BRACKET WITH MODIFIED COMPONENTS. THE RECALL BEGAN ON OCTOBER 28, 2004. OWNERS SHOULD CONTACT MITSUBISHI FUSO AT 1-877-711-0707. | |
| 1997 MITSUBISHI FUSO FM657 | |
|---|---|
| NHTSA Campaign ID: | INTERIOR LIGHTING |
| Manufacturer: | MITSUBISHI FUSO TRUCK OF AMERICA, INC. |
| Manufacture Dates: | 04/14/1995 - 12/23/2003 |
| Potential Units Affected: | 16101 |
Defect Description:ON CERTAIN TRUCKS, THE REBOUND CUSHION MAY STICK TO THE HOOK HINGE BRACKET, DUE TO IMPROPER RUBBER COMPOSITION OF THE CUSHION. THIS CONDITION COULD RESULT IN THE HOOK PIN BRACKET REMAINING IN THE UP (CAB CLOSED) POSITION WHEN THE CAB LATCH IS UNLOCKED. WITH THE HOOK PIN BRACKET IN THE UP POSITION, THE CAB TILT LOCK SWITCH REMAINS CLOSED, IMPROPERLY INDICATING THAT THE CAB LATCH IS LOCKED. Consequence:IF THE CAB LATCH IS UNLOCKED FOR ANY REASON, THE INSTRUMENT PANEL CAB LOCK INDICATOR WILL NOT NOTIFY THE DRIVER THAT THE CAB TILT LOCK MECHANISM IS IN THE UNLOCKED POSITION. A CRASH COULD OCCUR WITHOUT PRIOR WARNING. Action:DEALERS WILL REPLACE THE REBOUND CUSHION WITH A MODIFIED COMPONENT AND ADJUST THE CABLE TILT LOCK SWITCH AND BOTTOM BRACKET AT THE REAR CAB MOUNT. THE RECALL BEGAN ON OCTOBER 28, 2004. OWNERS SHOULD CONTACT MITSUBISHI FUSO AT 1-877-711-0707. | |
